Custom Autosound Manufacturing USA-630 manual Introduction, Problem Cause Solution

Problem	Cause	Solution
	Power Lead:Red Wire not	Check both fuse’s in filter
NO Lights, NO Sound	connected or Power not get-	box.Check all connections
	ting to radio. Orange wire not	on these wires and verify
	connected or power not get-	that radio is getting
	ting to radio.	12Volts on both wires.
	Power Lead:Orange Wire not	Check fuse in filter
Lights but No Sound	Connected or power not get-	box.Check all connections
	ting to radio	on this wire and verify that
		radio is getting 12Volts on
		this wire
	Problem with a speaker or	Verify all speakers used
Lights,Numbers	speaker wire	are 4ohm or greater. Verify
Displayed but No Sound		that none of the speakers
		are going to ground.
		Verify that none of the
		speaker wires are shorting
		to themselves or ground.
	Speaker wires disconnected	Check all connections
Sound only heard on	Balance control set to one	Adjust balance control to
one side	side	center position
Noise with Radio	Antenna not fully extended	Extend antenna to full
Reception	Car underneath Fluorescent	length.
	lights	Back vehicle out of garage
		and test again

Introduction

Thank you for your purchase of a Custom Autosound radio.

This factory made AM/FM receiver is specifically designed and manufactured for your classic special interest vehicle. It is a reflection of over 30 years of customer feedback regarding preferred features,vehicle compatibility, cosmetics and quality components.

The quality of the components and various parts that are used in our radios were devel- oped in a California audio research laboratory. The laboratory researched and assem- bled the finest affordable CDC controller radio tuner and amplifier sections.

Custom Autosound and its staff own over 16 classic special interest cars and trucks. These vehicles are used for research and development, car shows meets and much personal pleasure. We find that our custom radios only sound as good as the speakers they are matched with and a quality installation.

We also manufacture a full line of rear and dual front and dual voice coil speaker assemblies to fit in the original speaker areas, rear and overhead speaker assemblies and custom radios for over 300 different year groups and makes of classic vehicles plus Secretaudio the hideaway AM/FM CD Controller radio for any vehicle.

Your Custom Autosound authorized dealer has information regarding our speakers and special speaker assemblies, as well as information regarding custom radios for cars other than yours.

Again, we thank you for your purchase! You have increased the value and "Driving Pleasure" of your classic without damaging the originality.

Regards, Carl Sprague

President

Custom Autosound

It Is advised that you do Not return defective units to your dealer. There is generally no "exchange" e.g.(as is standard Electronics Industry Policy). Also, most dealers do not have radio technicians, test benches, etc and a return to factory through a dealer can

extend turn-around times by weeks!

Please call Custom Autosound, requesting technical assistance if a problem occurs. We will gladly trouble shoot/advise step by step.

If your unit is in need of repair, Please ship to us, UPS preferably. We will repair or replace and return ASAP! Normal turn around time is 7 business days plus shipping time.

Custom Autosound Mfg, Inc.	800-888-8637
1030 West Williamson Ave	Fax 714-773-1523
Fullerton, CA 92833	www.custom-autosound.com

13 2