Desa SDVBND, SDVBPD installation manual Table of Contents, Safety Information

2

TABLE OF CONTENTS SAFETY INFORMATION

TABLE OF CONTENTS
SAFETY INFORMATION	2
PRODUCT IDENTIFICATION	3
LOCAL CODES	4
PRODUCT FEATURES	4
GLOSSARY OF TERMS	4
PRE-INSTALLATION PREPARATION	4
CAST IRON STOVE AND DIRECT-VENT BURNER SYSTEM
ASSEMBLY	5
GENERAL VENTING	10
VENTING INSTALLATION	12
STOVE AND DIRECT-VENT BURNER SYSTEM INSTALLATION ..	20
OPERATING STOVE WITH BURNER SYSTEM	26

INSPECTING BURNERS		28
CLEANING AND MAINTENANCE		29
TROUBLESHOOTING		30
SPECIFICATIONS		33
WIRING DIAGRAM		33
REPLACEMENT PARTS		33
ILLUSTRATED PARTS BREAKDOWN AND PARTS LIST		34
TECHNICAL SERVICE		38
SERVICE HINTS		38
ACCESSORIES		38
OWNER'S REGISTRATION		39
WARRANTY INFORMATION	Back Cover

SAFETY INFORMATION

WARNINGS

WARNING: This product contains and/or generates chemicals known to the State of California to cause cancer or birth defects, or other reproductive harm.

IMPORTANT: Read this owner’s manual carefully and completely before trying to assemble, operate, or service this stove and burner system. Improper use of this stove and burner system can cause serious injury or death from burns, fire, explosions, electrical shock, and carbon monoxide poisoning.

DANGER: Carbon monoxide poisoning may lead to death!

This appliance complies with the current ANSI Z21.88 and CSA 2.33 as a Vented Gas Fireplace Heater and is listed and tested by the Canadian Standards Association to the above test standards. This stove with burner system is a vented product. This stove with burner system will not produce any gas leakage into your home if properly installed. This stove with burner system must be properly installed by a qualified serviceperson.Theglassdoormustbeproperlyseatedandsealed.Ifthis unit is not properly installed by a qualified service person with glass door properly seated and sealed, gas leakage can occur.

Carbon Monoxide Poisoning: Early signs of carbon monoxide poison- ing resemble the flu, with headaches, dizziness, or nausea. If you have these signs, the stove may not have been installed properly. Get fresh air at once! Have stove inspected and serviced by a qualified service person. Some people are more affected by carbon monoxide than others. These include pregnant women, people with heart or lung disease or anemia, those under the influence of alcohol, and those at high altitudes.

Natural and Propane/LP Gas: Natural and propane/LP gases are both odorless. An odor-making agent is added to each of these gases. The odor helps you detect a gas leak. However, the odor added to these gases can fade. Gas may be present even though no odor exists.

Make certain you read and understand all warnings. Keep this manual for reference. It is your guide to safe and proper operation of this stove and burner system.

WARNING: Any change to this stove or burner system or its controls can be dangerous.

1.This appliance is only for use with the type of gas indicated on the rating plate. This appliance is not convertible for use with other gases unless a certified kit is used.

2.For propane/LP burner system, do not place propane/LP supply tank(s) inside any structure. Locate propane/LP supply tank(s) outdoors. To prevent performance problems, do not use propane/ LP fuel tank of less than 100 lbs. capacity (propane/LP units only).

3.If you smell gas

•shut off gas supply

•do not try to light any appliance

•do not touch any electrical switch; do not use any phone in your building

•immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions

•if you cannot reach you gas supplier, call the fire department.

4.Never install the stove

•in a recreational vehicle

•where curtains, furniture, clothing, or other flammable ob- jects are less than 42" from the front, top, or sides of the stove

•in high traffic areas

•in windy or drafty areas

5.This stove reaches high temperatures. Keep children and adults away from hot surfaces to avoid burns or clothing ignition. Stove will remain hot for a time after shutdown. Allow surfaces to cool before touching.

For..com

112126-01B