Ducane 1605NG, 20529916 owner manual Troubleshooting, Problem

TROUBLESHOOTING

PROBLEM	CHECK and CURE	IMPORTANT
IGNITION SYSTEM	Be sure that there is gas fl ow to the burners by attempting to match light your burners.
	If match lighting is successful, the problem lies somewhere in the ignition system and
	will need to be checked.
MAIN GRILLING BURNERS		If the main burner(s) still fails to ignite, make
	CAUTION: Always turn the gas supply off at the tank before	sure that there is gas fl owing to the burner(s) by
		attempting to match light the burner(s). If the
	proceeding with any troubleshooting procedures.
		burners will match light, then proceed with the
	If, for any reason, the snap ignition fails to ignite the main grilling burner(s), repeat the	ignition checkout.
		If for any reason the igniter system is still
	lighting procedures described on the grill control panel.
		inoperative, follow match lighting instructions.

WARNING: The hood must be in the full open position any time you attempt to light your grill. Failure to open the hood could lead to delayed ignition resulting in bodily harm.

After shutting off the main gas supply, remove the cook grate and heat distribution plates. Turn snap igniter counter clockwise and check if the electrode is sparking to the igniter tube. Try the snap igniter several times.

ROTISSERIE BURNER ELECTRONIC	With a fresh battery installed, push electronic ignition button and check if there is a	Verify that the battery is in good condition and
IGNITION	spark between the two electrode tips. There needs to be a 1/8” to 3/16” gap between	installed correctly. If so, try a new battery.
	the electrode tips. If the gap is lesser or greater, carefully bend the electrode tips until	If for any reason the igniter system is still
	you have the correct gap of 1/8” to 3/16”(A).	inoperative, follow match lighting instructions.
BURNERS WITH POOR FLAME	Check to be sure burner ports, shutter, end of the burner (venturi) and orifi ce(s) are free	If you still have a poor fl ame, please contact
	of any obstructions. Also, if your grill has been stored over a prolonged period of time,	dealer for futher assistance or call Customer
	check to make sure no spiderwebs have been formed in the shutter end of the burner	Service
	(venturi) or over orifi ces.

On an LP grill, if an extremely low fl ame is present, or is hard to ignite, the

flow-limiting device may have activated. To reset the fl ow limiter turn all burners control knobs to “high”. Wait at least 1 minute. Turn burner control knobs “OFF”, reconnect the regulator to the cylinder. Turn cylinder valve on slowly. Refer to Lighting Insructions.

If problems cannot be corrected by using these methods, please contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.ducane.com.

A

19