Electrolux 131 instruction manual Engine, Other, Troubleshooting Table, Cause, Remedy

Models: 131

1 11
Download 11 pages 27.79 Kb
Page 9
Image 9
ENGINE

ENGINE

SRemove spark plug and pour 1 teaspoon of 40:1, 2-cycle engine oil (air cooled) through

the spark plug opening. Slowly pull the starter rope 8 to 10 times to distribute oil.

SReplace spark plug with new one of recom-

mended type and heat range.

SClean air filter.

S Check entire unit for loose screws, nuts, and bolts. Replace any damaged, broken, or worn parts.

S At the beginning of the next season, use only fresh fuel having the proper gasoline to oil ratio.

OTHER

SDo not store gasoline from one season to another.

S Replace your gasoline can if it starts to rust.

TROUBLESHOOTING TABLE

WARNING: Always stop unit and disconnect spark plug before performing all of the recommended remedies below except remedies that require operation of the unit.

 

TROUBLE

CAUSE

REMEDY

 

Engine will not

1. Engine flooded.

1. See “Starting a Flooded Engine” in

 

start.

2. Fuel tank empty.

 

Operation Section.

 

 

2. Fill tank with correct fuel mixture.

 

 

3. Spark plug not firing.

3. Install new spark plug.

 

 

4. Fuel not reaching

4. Check for dirty fuel filter; replace.

 

 

 

carburetor.

 

Check for kinked or split fuel line;

 

 

5. Carburetor requires

 

repair or replace.

 

 

5. See “Carburetor Adjustment” in

 

 

 

adjustment.

 

Service and Adjustments Section.

 

 

 

 

 

 

 

Engine will

1.

Carburetor requires

1.

See “Carburetor Adjustment” in

 

not idle

 

adjustment.

 

Service and Adjustments Section.

 

properly.

2.

Crankshaft seals worn.

2.

Contact an authorized service dealer.

 

 

3.

Compression low.

3.

Contact an authorized service dealer.

 

Engine will not

1.

Air filter dirty.

1.

Clean or replace air filter.

 

accelerate,

2. Spark plug fouled.

2.

Clean or replace plug

 

lacks power,

3.

Carburetor requires

 

and regap.

 

or dies under

3.

See “Carburetor Adjustment” in

 

a load.

 

adjustment.

 

Service and Adjustments Section.

 

 

4.

Carbon build-up on

4.

Contact an authorized service dealer.

 

 

 

muffler outlet screen.

 

 

 

 

5.

Compression low.

5.

Contact an authorized service dealer.

 

Engine

1.

Choke partially on.

1.

Adjust choke.

 

smokes

2.

Fuel mixture incorrect.

2.

Empty fuel tank and refill with

 

excessively.

3.

Air filter dirty.

 

correct fuel mixture.

 

 

3.

Clean or replace air filter.

 

 

4.

Carburetor requires

4.

See “Carburetor Adjustment” in

 

 

 

adjustment.

 

Service and Adjustments Section.

 

Engine runs

1. Fuel mixture incorrect.

1.

See “Fueling Engine” in Operation

 

hot.

 

 

 

section.

 

 

2. Spark plug incorrect.

2.

Replace with correct spark plug.

 

 

3. Carburetor requires

3.

See “Carburetor Adjustment” in

 

 

 

adjustment.

 

Service and Adjustments Section.

 

 

4. Carbon build-up on

4.

Contact an authorized service dealer.

 

 

 

muffler outlet screen.

 

 

9

Page 9
Image 9
Electrolux 131 instruction manual Engine, Other, Troubleshooting Table, Cause, Remedy