Euro-Pro VPW38H Safety & Warning Instructions, Trouble Shooting, Danger, Problem, Possible Reason

SERVICING OF A DOUBLE-INSULATED APPLIANCE.

In a double-insulated product, two systems of insulation are provided instead of grounding. No grounding means are provided for a double-insulated product, nor should grounding means be added to the product. Servicing a double-insulated product requires extreme care and knowledge of the system and should be done only by qualified service personnel. Replacement parts for a double-insulated product must be identical to the

original parts. A double-insulated product is marked with the words " double Insulation" or "Double Insulated". Product may also be marked with symbol shown.

9. Keep operation area clear of all persons.

10. Do not overreach or stand on unstable support. Keep good footing and balance at all times.

11. Follow maintenance instructions specified in this manual.

12. This product shall be connected to a power supply receptacle protected by a ground fault circuit interrupter (GFCI) (electric power washers only).

13. If product is provided with a GFCI, be sure to inspect the cord and GFCI prior to use. Any repair or replacement of the power cord must be performed by a qualified (licensed or certified) electrical technician.

TROUBLE SHOOTING

PROBLEM		POSSIBLE REASON	POSSIBLE SOLUTION
PRESSURE			1.	Check plug, socket, fuses,
	1. Electrical socket is faulty or			breaker.
WASHER WILL
		breaker has tripped.	2.	Check that the voltage is
NOT START WHEN
	2.	Voltage is inadequate.		adequate.
THE ON/OFF
	3.	GFCI has tripped.	3.	Reset/Try another electrical
SWITCH IS IN THE
	4. Power cord is not plugged in.			outlet.
"ON" POSITION
			4.	Plug in power cord.
			1.	Remove and clean water
PUMP DOESN'T	1.	Water intake filter is clogged.		intake filter.
			2.	Tighten connections/bleed
REACH	2.	Pump is drawing air.
				system.
ADEQUATE	3.	Diameter of garden hose is
			3.	Replace with 3/4 inch
PRESSURE OR		too small.
				garden hose.
CAVITATES	4.	Water supply is restricted.
			4.	Check hose for kinks or
				leaks, open tap fully.
PRESSURE			1.	Turn unit and water supply
	1.	Excessive air in waterline and		off/Bleed system/Hold
WASHER HAS OR				trigger down. Allow water to
WILL NOT	2.	pump.		flow through the pump for
MAINTAIN		Water supply is restricted.	2.	30 seconds.
PRESSURE				Check hose for kinks or
				leaks, open tap fully.
PRESSURE	1.	Air intake is blocked.	1.	Clean the air intake vents.
WASHER MAKES
	2.	Water intake filter is dirty.	2.	Check & clean filter.
EXCESSIVE NOISE
MOTOR DOES
NOT RUN
CONTINUOUSLY
WHEN TRIGGER IS
SQUEEZED/
MOTOR BUZZES	1.	Net voltage is lower than	1.	Check that the voltage is
WHEN TURNED
		suggested.		adequate.
ON BUT DOES
NOT
START/MOTOR
STOPS RUNNING
WHILE UNIT IS IN
USE

SAFETY & WARNING INSTRUCTIONS

For safety reasons, it is recommended that you read this manual before attempting to operate this appliance. Failure to follow these instructions can result in personal injury or equipment problems. To help recognize note the following symbols:

DANGER

Danger indicates an imminently hazardous situation, which, if not avoided, WILL result in death or serious injury.

WARNING

Warning indicates a potentially hazardous situation, which, if not avoided, COULD result in death or serious injury.

	CAUTION
			WARNING
Caution indicates a potentially hazardous
		Risk of injection or severe injury. Keep clear
situation, which, if not avoided, MAY result in
		of nozzle. Do not discharge streams at
death or serious injury.
		persons. This product is to be used only by
NOTE: Information that requires special		trained operators. Always remove lance
attention.		from gun before cleaning debris from tip.
		• Keep clear of nozzle. NEVER direct high
Important Safety Instructions SAVE THESE		pressure spray at any person, animal or
INSTRUCITONS		self.
		• Always wear safety goggles or glasses
When using this product, basic precautions		and protective clothing when operating,
should always be followed, including the		performing maintenance or changing
following:		accessories.
		• Never put hands or fingers over the spray
		tip while operating the unit.
	DANGER	• Never try to stop or deflect leaks with any
		body part.
1. Read all instructions before using the		• Always engage the trigger safety latch in
		the safe position when spraying is
product.		stopped even if only for a few minutes.
2. To reduce the risk of injury, close		• Always follow detergent manufacturer's
supervision is necessary when this		label recommendations for proper use of
product is used near children.		detergents. Always protect eyes, skin and
3. Always disconnect power (electric units)		respiratory system from detergent use.
before disassembling, repairing or
changing attachments on the unit.			WARNING
4. Follow all safety codes as well as the
Occupational Safety and Health Act
(OSHA).
5. Ensure safety devices are operating
properly before each use. DO NOT
remove or modify any part of the gun or
unit.
6. Know how to stop this unit and relieve
pressure quickly. Be thoroughly familiar
with the controls.
7. Stay alert - Watch what you are doing.
8. Do not operate this unit when fatigued or
under the influence of alcohol or drugs.

8 Rev. 02/04B

1