Hearth and Home Technologies GBFL4136I, GBST4336I B. Service Parts List GBFL4136I

47

Heatilator • GBST4336I, GBFL4136I • 2135-900 Rev. B • 3/08

B. Service Parts List GBFL4136I

IMPORTANT : THIS IS DATED INFORMATION. When requesting service or replacement

parts for your appliance please provide model number and serial number. All parts listed

in this manual may be ordered from an authorized dealer. Stocked

at Depot

ITEM DESCRIPTION SERIAL # PART NUMBER

Log Set Assembly LOGS-2129 Y

A Log A SRV2129-701 N

B Log B SRV2129-703 N

C Log C SRV2129-702 N

D Log D SRV2129-706 N

1 Log 1 SRV2129-704 N

2 Log 2 SRV2129-705 N

3 Log 3 SRV2129-707 N

4 Sheetrock Ledge (side) 2130-118 N

5 Refractory Panel 2135-017 N

6 Burner NG, LP 2128-007 Y

7 Pilot Shield 2128-124 N

8 Base Pan 2132-115 N

9 Glass Door Assembly (Side) GLA-750TR Y

10 Thermostat Wire 2118-170 Y

11 Junction Box 4021-013 Y

12 Junction Box Bracket 2128-128 N

13 Glass Door Assembly (End) GLA-2130 Y

14 Sheetrock Ledge (End) 2130-126 N

Surround Overlay Kit SRV2130-FACE N

Glass Latch Assembly 386-122A Y

Limit Switch Assembly 2134-052 y

72 Inch Wire Assembly 258-501A Y

80 Inch Wire Asembly 522-501A Y

Gasket Assembly

2128-081 N

Contains Vent, Seal Cap, Burner Neck, Shutter Bracket

and Valve Plate Gaskets

Mineral Wool 050-721 N

Lava Rock 2005-790 N

Touch Up Paint TUP-GBK-12 N

Conversion Kit NG NGK-MS36 Y

Conversion Kit LP LPK-MS36 Y

Pilot Oriﬁ ce NG 593-528 Y

Pilot Oriﬁ ce LP 593-527 Y

Regulator NG NGK-DXV Y

Regulator LP LPK-DXV Y

Additional service part numbers appear on following page.

Î

Contents

Main Owners Manual NOTICE DO NOT DISCARD Model: GBST4336I GBFL4136I Listing Label Information/Location Heatilator GBST4336I, GBFL4136I 2135-900 Rev. B 3/08 Model Number Serial Number A. Congratulations Table of Contents User Guide Installer Guide Page B. Limited Lifetime Warranty Gas Appliance (Fireplace) Limited Lifetime Warranty Limited Lifetime Warranty 1 Year Limited Warranty Conditions, Exclusions, & Limitations of Liability How to Obtain Service 1 B. Tempered Glass Speci cations C. BTU Speci cationsA. Appliance Certi cation E. Non-Combustible Materials Speci cation F. Combustible Materials Speci cation 2 B. Your Fireplace User Guide A. Gas Fireplace Safety C. Clear Space G. Outside Air (optional) E. Fixed Glass Assembly D. Decorative Doors and Fronts F. Remote Controls, Wall Controls and Wall Switches CAUTION: NOT FOR USE WITH SOLID FUEL WARNING: DO NOT CONNECT 110 VAC TO THE CONTROL VALVE. J. After Fireplace is Lit K. Frequently Asked Questions 3 Glass Cleaning 3 A. Maintenance Tasks-Homeowner Doors, Surrounds, Fronts Remote Control Venting B. Maintenance Tasks-Quali ed Service Technician Gasket Seal and Glass Assembly Inspection Logs Firebox Control Compartment and Firebox Top 4 Installer Guide 4 Heatilator GBST4336I, GBFL4136I 2135-900 Rev. B 3/08 A. Typical Appliance System NOTE: MUST TERMINATE VERTICALLY Figure 4.1 Typical System B. Design and Installation Considerations D. Inspect Appliance and Components C. Tools and Supplies Needed E. Negative Pressure 5 A. Selecting Appliance Location B. Constructing the Appliance Chase C. Clearances C A Figure 5.3 Clearances to Combustibles, Model GBFL4136I F H D. Mantel and Wall Projections MIN. 910 10 9 Combustible Mantel Legs or Wall Projections 6 A. Vent Termination Minimum Clearances 6 7 B. Vent System Con guration A. Vent Guidelines A. Pipe Clearances to Combustibles 8 B. Wall and Ceiling Penetration Framing C. Vertical Penetration Framing 9 A. Installing Outside Air Kit Damper Assem- bly 9 B. Gas and Electrical Connections C. Securing and Leveling the Appliance 10 10 A. Assembly of Vent Sections B. Attaching Vent to Firebox C. Securing Vent Sections 11 A. Fuel Conversion B. Gas Pressure C. Gas Connection 11 12 A. Wiring Requirements B. Intelli re Ignition System Wiring C. Optional Accessories Requirements 12 D. Electrical Service and Repair E. Junction Box Installation 13 A. Mantel and Wall Projections TO CEILING MIN. 910 B. Facing Material C. Splatter Guard Page 14 A. Remove Glass Assembly B. Remove the Shipping Materials C. Clean the Appliance D. Accessories Page Page Page I. Air Shutter Setting G. Fixed Glass Assembly Removing Fixed Glass Assembly H. Install Trim Kits and Surrounds Removing Fixed Glass Assembly 15 15 A. Intelli re Ignition System Symptom Possible Cause Corrective Action Intelli re Ignition System - (continued) Symptom Possible Cause Corrective Action 16 16 A. Appliance Dimension Diagram Page Page GBST4336I B. Service Parts Page B. Service Parts List GBFL4136I Service Parts GBST4336I, GBFL4136I IPI Valve Assembly NOTICE