Lennox Hearth C160, CA160, SWI160 operation manual

INSTALLATION AND OPERATION MANUAL

WARNINGS

•

Hot! Do not touch! The glass and surfaces of this appliance will

be hot during operation and will retain heat for a while after

shutting off the appliance. Severe burns may result.

•

Carefully supervise children in the same room as appliance.

Save These Instructions

For Future Reference

A French manual is available upon request. Order P/N 775211CF.

Ce manuel d’installation est disponible en francais, simplement en faire la demande. Numéro de

la pièce 775211CF.

This appliance must be properly installed and operated in order to prevent the

possibility of a house ﬁre. Please read this entire installation and operation

manual before installing and using your wood ﬁreplace insert. Failure

to follow these instructions could result in property damage, bodily

injury or even death. Contact your local building or ﬁre ofﬁcials

to obtain a permit and information on any installation re-

quirements and inspection requirements in your area.

EPA Certiﬁed

Wood-Burning

Fireplace Insert

P/N 775211M, Rev. C, 09/2011

US

Portland

Wood Fireplace Inserts

Striker™ Models C/A160 and SWI160

Striker™ CA160

Striker™ C160

and SWI160

Report # 050-S-03b-2

Contents

Main INSTALLATION AND OPERATION MANUAL Save These Instructions For Future Reference EPA Certied Wood-Burning Fireplace Insert Wood Fireplace Inserts Striker Models C/A160 and SWI160 CONGRATULATIONS! TABLE OF CONTENTS IMPORTANT SAFETY AND WARNIING INFORMATION READ THIS MANUAL IN ITS ENTIRETY AND UNDER- STAND THESE RULES TO FOLLOW FOR SAFETY. TESTING INFORMATION DRAFT REQUIREMENTS SELECTING THE PROPER VENTING SYSTEM Chimney Height Requirements Figure 1 NEGATIVE PRESSURE WARNING CREOSOTE, FORMATION AND NEED FOR REMOVAL BURN-IN PERIOD DISPOSAL OF ASHES FUEL Figure 3 Figure 4 Firebrick Diagram Figure 2 BRICK INSTALLATION REQUIRED CLEARANCES Figure 6 ** u u Table 1 - Fireplace Sizing HEARTH PROTECTION SEE TABLE 3 ON FOLLOWING PAGE FOR CANADA REQUIRE- MENTS CHIMNEY REQUIREMENTS INSTALLATION PROCEDURES - MASONRY CHIMNEY u POSITIVE FLUE CONNECTION Figure 7 - Connector Ring Kit Direct Connect Positive Flue Connection Required in Canada } SIDE VIEW v w v w WARNING CHIMNEY LINER INSTALLATION POST INSTALLATION CHECKS INSTALLING THE INSERT OK CAUTION BLOWER OPERATION Figure 11 - Blower Controls Figure 12 - Blower Wiring Schematic NOTE: Turn blower off before opening the door to load the fuel. OPERATING TECHNIQUES AND HINTS ACHIEVING CLEAN, LONG BURNS GETTING THE MOST OUT OF YOUR FIREPLACE INSERT MAXIMIZING YOUR FIREPLACE INSERTS OVERALL EFFICIENCY WARNINGS Figure 13 MAINTENANCE CAUTION TROUBLESHOOTING DOS AND DONT REPLACEMENT PARTS - MODELS CA160,C160 AND SWI160 Page REPLACEMENT PARTS - MODELS CA160, C160 AND SWI160 Door Parts Blower Parts ACCESSORIES - MODELS CA160, C160 AND SWI160 Page WARRANTY REPLACEMENT PARTS PRODUCT REFERENCE INFORMATION