Lennox Hearth Winslow (PS40)

NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.

Door Grill Installation Instructions

Parts Needed:

Qty

(4) Button Head Screws (already in place in stove)

Tools Required:

Qty

(1) 1/8” allen wrench

To install the Grill:

1. Remove the four button head screws from body of the stove with a

1/8” allen wrench. See Figure 29.

2. Pull the scraper rod out, rotate the grill vertically, (with the notch to

the left) and slide the grill over the scraper rod (slide the rod between

the third and fourth bar). See Figure 30.

3. Rotate the grill back to the horizontal position and re-install the four

button head screws through the two holes at each end of the grill and

into the stove body. See Figure 31.

Figure 30

Figure 31

Figure 32

Figure 29

Rotate Grill Back To Horizontal Position

Slider Rod

Between 3rd and 4th Bar

Notch

Re-install Button Head Screws

Button Head Screw

Contents

Main INSTALLATION AND OPERATION MANUAL Save These Instructions For Future Reference Pellet Stoves Model Winslow (PS40) DRAFT 11/18/08(2) IMPORTANT SAFETY AND WARNIING INFORMATION READ THIS MANUAL IN ITS ENTIRETY AND UNDER- STAND THESE RULES TO FOLLOW FOR SAFETY . WARNING WARNING CONGRATULATIONS! TABLE OF CONTENTS PRODUCT IS SUBJECT TO CHANGE WITHOUT NOTICE USING THIS MANUAL PLANNING YOUR INSTALLATION WARNING Electrical Electrical Generator Operation Questions To Ask Local Building Ofcial WARNING SELECTING A LOCATION CAUTION Ventilation Requirements - FEATURES AND SPECIFICATIONS CAUTION THE USE OF UNAPPROVED, DIRTY, WET AND/OR HIGH SALT CONTENT FUEL WILL VOID THE WAR- RANTY! Installation Options Heating Venting IMPORTANT Page HEARTH PROTECTION VENT TERMINATION REQUIREMENTS Figure 8 Figure 9 Minimum Size Hearth Protection Figure 10 Stove Base Firebox Front Edge Hearth Protection Outline of Stove Base 3-7/8 Page Venting INSTALLATION Figure 13 45 90 Figure 14 Figure 12 Figure 15 Page Wiring Block B A Rear View of Control Board Page Page Page Brick Panel Installation Figure 34 A B Figure 35 Figure 33 Figure 36 Figure 37 E OPERATION Control Board Figure 42 Filling the Hopper Lighting WARNINGS 234 1 Off High Heat Selector Knob Page Page C A Figure 46B Figure 48 D Figure 47 Cleaning the Vent Pipe Figure 46A Cleaning the Convection Blower Proof of Fire Switch Front Door Removal CAUTION: Do not open the front door when the stove is hot. Figure 50 Side Door Removal Back Removal and Lower Cover Plate B E C D A Draft Adjuster Page Page 29 Door Trim Grill Kits Common Accessories ACCESSORIES WARRANTY PRODUCT REFERENCE INFORMATION REPLACEMENT PARTS