G40DF(X) Parts Identification
CABINET
BLOWER
MOTOR
CONTROL BOX
DURALOKTM HEAT
EXCHANGER
ASSEMBLY
COMBUSTION AIR
INDUCER
FLUE
COLLAR
TOP CAP
FLUE CHASE
BLOWER ACCESS
PANEL
SURELIGHTt
CONTROL BOARD
COMBUSTION AIR
PROVING
(PRESSURE) SWITCH
GAS
VALVE
GAS
MANIFOLD
LOWER ACCESS
PANEL
BURNERS
FIGURE 1
WARNING
Product contains fiberglass wool.
Disturbing the insulation in this product during installation, maintenance, or repair will expose you to fiberglass wool. Breathing this may cause lung cancer. (Fiberglass wool is known to the State of Cal0 ifornia to cause cancer.)
Fiberglass wool may also cause respiratory, skin, and eye irritation.
To reduce exposure to this substance or for further information, consult material safety data sheets available from address shown below, or contact your supervisor.
Lennox Industries Inc.
P.O. Box 799900
Dallas, TX
NOTE - This manual must be left with the equipment user.
WARNING
Do not set thermostat below 60°F (16°C) in heating mode. Setting thermostat below 60°F (16°C) reduces the number of heating cycles. Damage to the unit may occur that is not covered by the warranty.
WARNING
If overheating occurs or if gas supply fails to shut off, shut off the manual gas valve to the appliance before shutting off electrical supply.
CAUTION
Before attempting to perform any service or mainte0 nance, turn the electrical power to unit OFF at the disconnect switch.
