Contents
GB
65001022 Issue 2. V700 Windlass. |
| ||
Introduction | 4 | ||
|
|
| |
| Product support | 4 | |
|
|
|
|
|
| Approvals | 4 |
|
|
| |
Safety notices | 4 | ||
|
|
| |
| General | 4 | |
|
|
| |
| Electrical | 4 | |
|
|
| |
| Electromagnetic compatibility | 4 | |
|
|
| |
| Important information about this manual | 4 | |
|
|
| |
1. Installation | 5 | ||
|
|
| |
1.1 | Gypsy Suitability | 5 | |
|
|
|
|
1.2 | Package contents | 5 | |
|
|
|
|
1.3 | Additional requirements | 5 | |
|
|
|
|
1.4 | Accessories | 5 | |
|
|
|
|
1.5 | Specifications | 5 | |
|
|
|
|
1.6 | Fitting the windlass to the deck | 5 | |
|
|
|
|
4. | Maintenance | 10 | |
| 4.1 | General recommendations | 10 |
|
|
| |
5. | Dismantling procedures | 10 | |
|
|
|
|
| 5.1 | Gypsy replacement | 10 |
|
|
|
|
| 5.2 | Control arm replacement | 10 |
|
|
|
|
| 5.3 | Main shaft lubrication | 10 |
|
|
|
|
| 5.4 | Fall safe pawl replacement | 10 |
|
|
|
|
| 5.5 | Fall safe lever replacement | 10 |
|
|
| |
6. | Troubleshooting | 11 | |
|
|
|
|
| 6.1 | Anchor rode pays out independently while |
|
| windlass is not in use | 11 | |
|
|
|
|
| 6.2 | Electrical troubleshooting | 11 |
|
|
| |
7. | Parts list | 12 | |
|
|
|
|
| 7.1 | Service kits | 13 |
|
|
|
|
| 7.2 | Parts list key | 13 |
|
|
|
|
2. Electrical wiring installation | 7 | |||
2.1 | Electric cable selection | 7 | ||
|
|
|
| |
2.2 | Wiring | 7 | ||
|
|
|
| |
2.3 | Control switch installation | 7 | ||
|
|
|
|
|
2.4 | V700 | Wiring diagram (toggle switch) | 8 | |
|
|
|
|
|
2.5 | V700 | Wiring diagram (contactor) | 8 | |
|
|
|
|
|
3. Operating your windlass | 9 | ||
3.1 | Safety first | 9 | |
|
|
|
|
3.2 | Use of clutch | 9 | |
|
|
|
|
3.3 | Letting go under gravity | 9 | |
|
|
|
|
3.4 | Letting go under power | 9 | |
|
|
|
|
3.5 | Lying to anchor safely | 9 | |
|
|
|
|
3.6 | Hauling in | 9 | |
|
|
|
|
3.7 | Manual recovery | 9 | |
|
|
|
|
3.8 | Operating tips | 9 | |
|
|
|
|
3.9 | Joining rope to chain | 9 | |
|
|
|
|
8. Lewmar limited warranty | 14 |
To the best of our knowledge, the information in this manual was correct when it went to press. However, Lewmar cannot accept liability for any inaccuracies or omissions it may contain. In addition, our policy of continuous product improvement may change specifications without notice. As a result, Lewmar cannot accept liability for any differences between the product and the manual.
This manual forms part of the product and MUST BE RETAINED along with, OR incorporated into, the Owner’s Manual for the vessel to which the windlass is fitted.
V700 Windlass | 3 |
