Manuals / Monessen Hearth / Household Appliance / Indoor Fireplace

Monessen Hearth HWB700HB manual Chimney Installation

Models: HWB700HB

1 36

Page 15

CHIMNEY INSTALLATION
			TABLE 1
FIGURE 15		MINIMUM REQUIRED ROOF OPENING
FIGURE 15		MINIMUM FRAMED OPENING
	ACTUAL		"L" SERIES
CENTERLINE	CENTER POINT	ROOF PITCH	DOUBLEWALL CHIMNEY
CENTERLINE
OF CHIMNEY		0/12	17" x 17"
		0/12	17" x 17"
		1 12	17" x 17" 1/8"
		2/12	17" x 17" 1/4"
		3 12	17" x 17" 1/2"
		4/12	17" x 17" 3/4"
	PLUMB LINE	5 12	17" x 18" 1/4"
		6/12	17" x 18" 3/4"
		7 12	17" x 19" 3/8"
		8/12	17" x 20"
		9 12	17" x 20" 5/8"
	PLUMB BOB	10/12	17" x 21" 3/8"
	PLUMB BOB	11 12	17" x 22" 1/4"
		11 12	17" x 22" 1/4"
		12 12	17" x 23"
	IMAGINARY
	CENTER POINT
		INSTALLATION OF FIRESTOP-SPACER AT ATTIC LEVEL
			INLET AIR PIPE	FIGURE 17
		CEILING JOIST	FLUE PIPE
			FLUE PIPE
FIGURE 16
		HEADER	FIRESTOP SPACER
	OUTER PIPE	HEADER
	OUTER PIPE
	FLUE		CHIMNEY SECTION
			CHIMNEY SECTION
		INSTALLATION OF FIRESTOP-SPACER AT FLOOR LEVELS
	SUPPORT STRAPS
	FASTEN SECURELY	INLET AIR PIPE
		INLET AIR PIPE	FLUE PIPE
			FLUE PIPE
				FLOOR JOIST
	FIRESTOP
	CHIMNEY
	SUPPORT
	SNAP LOCK CHIMNEY
	SUPPORT SECURELY		FIRESTOP SPACER
	TO LOWER PIPES	HEADER	FIRESTOP SPACER
	TO LOWER PIPES	HEADER
	BEFORE FASTENING
	SUPPORT STRAPS		CHIMNEY SECTION
			CHIMNEY SECTION
				14
			53D9036. Rev 1 03/03

Page 15

Image 15

Monessen Hearth HWB700HB manual Chimney Installation

Contents

INSTALLATION, OPERATION AND MAINTENANCE MANUAL FOR RESIDENTIAL INSTALLATIONHWB700/HWB700HB MODELS TABLE OF CONTENTS CONGRATULATIONSLISTING AND CODE APPROVALS IMPROPER INSTALLATION IMPORTANT INFORMATIONINTENDED PRODUCT USAGE OPERATION GUIDELINES RESIDENTIAL INSTALLATION CLEARANCES34 9 3/4 26 3/8 155/8 9/16 CLEARANCESL SERIES CHIMNEY SECTIONS OUTER PIPE 4 1/2CAUTION Do not install fireplace over carpeting FIREPLACE LOCATIONINSTALLATION PREPARATION PREFERRED LOCATION POOR LOCATION INSTALLATION PREPARATIONSINGLE STORY INSTALLATION WITH ATTIC SPACE MULTIPLE STORY INSTALLATIONSB5400SS MINIMUM HEARTH EXTENSION DIMENSIONS FLOOR PROTECTIONThe ability of insulating material to retard the transfer of heat may be expressed as either Thermal Conduc- tance C, Thermal Conductivity K, or Thermal Resistance R. The mathematical relationship of these values and the formulas for converting one value to another is as follows FLOOR PROTECTION53D9036. Rev 1 03/03 FIREPLACE COMPONENTSFIREPLACE INSTALLATION 24 MIN CHIMNEY INSTALLATIONCHIMNEY INSTALLATION CHIMNEY OFFSET INSTALLATION ELBOW INSTALLATION53D9036. Rev 1 03/03 2 MIN. AIR SPAC CHIMNEY OFFSET AND CAP INSTALLATIONCHIMNEY MUST BE ENCLOSED IN ACCESSIBLE AREAS STORM COL FLASHICHIMNEY CAP INSTALLATION MODEL LC CHIMNEY CAP53D9036. Rev 1 03/03 CHIMNEY HEIGHT AND OFFSET CHARTS CHIMNEY CAP CHASE INSTALLATION INSTALLATION ABOVE BASEMENT OR CRAWL SPACE OUTSIDE COMBUSTION AIR RECOMMENDATIONS CONTINUED COMBUSTION AIR ASSEMBLY MODEL AK-4COMBUSTION AIR ASSEMBLY53D9036. Rev 1 03/03 IMPORTANT NOTICES GAS APPLIANCE INSTALLATIONGAS APPLIANCE INSTALLATION APPLYING DECORATIVE TRIM TO THE FIREPLACE53D9036. Rev 1 03/03 FIGURE 26A TRIM AND DOOR INSTALLATIONGLASS DOOR INSTALLATION 53D9036. Rev 1 03/03WHICH WOODS ARE BEST? FIREPLACE OPERATIONHOW TO BUILD A BETTER FIRE ADVANTAGES OF A WOOD BURNING FIREPLACEHEAT VALUE FIREPLACE OPERATIONSPECIES DENSITYDISPOSAL OF ASHES MAINTENANCE AND SAFETYCHIMNEY MAINTENANCE FUEL STORAGEDO’S MAINTENANCE AND SAFETYDONT’S MAINTENANCE AND SAFETYPARTS DIAGRAM AND LIST Technical Service Department2813 W. Mall Drive, Unit B. Florence, Alabama PARTS DIAGRAM AND LIST Technical Service Department2813 W. Mall Drive, Unit B. Florence, Alabama LIMITED WARRANTY EXCEPT BLOWERSFACTORY-BUILTFIREPLACE AND COMPONENTS YOUR DUTIES LIMITED WARRANTYTechnical Service Department 2813 W. Mall Drive, Unit B. Florence, AlabamaPLEASE RETURN THESE OPERATING 53D9036. REV 1 03/03APPLIANCE INSTALLER AND INSTALLATION INSTRUCTIONS

TABLE 1