Manuals / Poulan / Lawn and Garden / Lawn Mower

Poulan 190944 To Replace Headlight Bulb, Interlocks And Relays, To Replace Fuse, Engine

Models: 190944

1 48

Download 48 pages 17.24 Kb

Page 23

TO REPLACE HEADLIGHT BULB

SERVICE AND ADJUSTMENTS

•Lift seat pan to raised position.

•Disconnect BLACK battery cable ﬁrst then RED battery cable and carefully remove battery from tractor.

•Install new battery with terminals in same position as old battery.

•First connect RED battery cable to positive (+) terminal with hex bolt and keps nut as shown. Tighten securely. Slide terminal cover over terminal.

•Connect BLACK grounding cable to negative (-) ter- minal with remaining hex bolt and keps nut. Tighten securely.

SEAT PAN

FIG. 29

	TERMINAL	KEPS
		NUT
	COVER

HEX

BOLT

POSITIVE (RED)	NEGATIVE
CABLE	(BLACK) CABLE

FIG. 30

TO REPLACE HEADLIGHT BULB

•Raise hood.

•Pull bulb holder out of the hole in the backside of the grill.

•Replace bulb in holder and push bulb holder securely back into the hole in the backside of the grill.

•Close hood.

INTERLOCKS AND RELAYS

Loose or damaged wiring may cause your tractor to run poorly, stop running, or prevent it from starting.

•Check wiring. See electrical wiring diagram in the Repair Parts section.

TO REPLACE FUSE

Replace with 20 amp automotive-type plug-in fuse. The fuse holder is located behind the dash.

TO REMOVE HOOD AND GRILL ASSEMBLY (See Fig. 31)

•Raise hood.

•Unsnap headlight wire connector.

•Stand in front of tractor. Grasp hood at sides, tilt toward engine and lift off of tractor.

•To replace, reverse above procedure.

HOOD

HEADLIGHT

WIRE

CONNECTOR

02778

FIG. 31

ENGINE

TO ADJUST THROTTLE CONTROL CABLE

The throttle control has been preset at the factory and adjustment should not be necessary. If adjustment is nec- essary, see engine manual.

TO ADJUST CHOKE CONTROL

The choke control has been preset at the factory and ad- justment should not be necessary. If adjustment is neces- sary, see engne manual.

TO ADJUST CARBURETOR

Your carburetor is not adjustable. If your engine does not operate properly due to suspected carburetor problems, take your tractor to an authorized service center for repair and/or adjustment.

23

Image 23

Poulan 190944 To Replace Headlight Bulb, Interlocks And Relays, To Replace Fuse, TO REMOVE HOOD AND GRILL ASSEMBLY See Fig

Contents

LAWN TRACTOR MODELIMPORTANT MANUAL OWNERS MANUALI. GENERAL OPERATION SAFETY RULESIV. SERVICE Safe Operation Practices for Ride-OnMowersSafe Operation Practices for Ride-OnMowers SAFETY RULESCUSTOMER RESPONSIBILITIES TABLE OF CONTENTSPRODUCT SPECIFICATIONS Slope Sheet UNASSEMBLED PARTSSteering Wheel SeatTO REMOVE TRACTOR FROM CAR- TON ASSEMBLYTOOLS REQUIRED FOR ASSEMBLY INSTALL SEAT See Fig.ASSEMBLY CHECK BATTERY See Fig.ASSEMBLE GAUGE WHEELS TO MOWER DECK See Fig. CHECK FOR PROPER POSITION OF ALL BELTS TO CONVERT TO BAGGING OR DISCHARGINGCHECK TIRE PRESSURE CHECK DECK LEVELNESSOPERATION OPERATION KNOW YOUR TRACTORTO SET PARKING BRAKE See Fig. HOW TO USE YOUR TRACTORTO ADJUST MOWER CUTTING HEIGHT See Fig. TO ADJUST GAUGE WHEELS See Fig.TOWING CARTS AND OTHER ATTACHMENTS TO OPERATE MOWER See Fig.TO OPERATE ON HILLS TO TRANSPORT See Figs. 6 andTO START ENGINE See Fig. BEFORE STARTING THE ENGINECHECK ENGINE OIL LEVEL ADD GASOLINEOPERATION MOWING TIPSMULCHING MOWING TIPS GENERAL RECOMMENDATIONS MAINTENANCELUBRICATION CHART MAINTENANCE SCHEDULETIRES BATTERYTRACTOR BRAKE OPERATIONTRANSAXLE COOLING CLEAN AIR SCREENENGINE V-BELTSIN-LINEFUEL FILTER See Fig. CLEANINGMUFFLER SPARK PLUGSTO REMOVE MOWER See Fig. SERVICE AND ADJUSTMENTSTO INSTALL MOWER See Fig. TO LEVEL MOWER HOUSINGFIG. TO CHECK AND ADJUST BRAKE See Fig.TO REPLACE MOWER BLADE DRIVE BELT See Fig. SERVICE AND ADJUSTMENTSSERVICE AND ADJUSTMENTS TO REPLACE MOTION DRIVE BELT See Fig.REPLACING BATTERY See Figs. 29 and TRANSMISSION REMOVAL/REPLACEMENTTO ADJUST STEERING WHEEL ALIGN- MENT TO START ENGINE WITH A WEAK BATTERY See Fig.TO ADJUST CARBURETOR TO REMOVE HOOD AND GRILL ASSEMBLY See Fig.TO ADJUST THROTTLE CONTROL CABLE TO ADJUST CHOKE CONTROLENGINE OIL STORAGEOTHER FUEL SYSTEMCORRECTION TROUBLESHOOTING POINTSPROBLEM CAUSEEngine continues to run TROUBLESHOOTING POINTSWIRING INSULATED CLIPS SCHEMATICTRACTOR - - MODEL NUMBER PD185H42ST PD185H42STB IGNITION SWITCH33 30 ELECTRICALTRACTOR - - MODEL NUMBER PD185H42ST PD185H42STB DESCRIPTION TRACTOR - - MODEL NUMBER PD185H42ST PD185H42STBELECTRICAL PARTchassis_elite sv_pro_4 CHASSISTRACTOR - - MODEL NUMBER PD185H42ST PD185H42STB 9187846X012 Dash P/L TRACTOR - - MODEL NUMBER PD185H42ST PD185H42STBCHASSIS DESCRIPTIONTRACTOR - - MODEL NUMBER PD185H42ST PD185H42STB DRIVEDRIVE TRACTOR - - MODEL NUMBER PD185H42ST PD185H42STBsteering_pl.lt_47 STEERING ASSEMBLYTRACTOR - - MODEL NUMBER PD185H42ST PD185H42STB KEY PART NO. NO. DESCRIPTION STEERING ASSEMBLYTRACTOR - - MODEL NUMBER PD185H42ST PD185H42STB TRACTOR - - MODEL NUMBER PD185H42ST PD185H42STB SEAT ASSEMBLYTRACTOR - - MODEL NUMBER PD185H42ST PD185H42STB DECALSWHEELS AND TIRES Spark Arrester ENGINETRACTOR - - MODEL NUMBER PD185H42ST PD185H42STB OPTIONAL EQUIPMENTTRACTOR - - MODEL NUMBER PD185H42ST PD185H42STB MOWER LIFT42_deck_man-t-path_4 MOWER DECKTRACTOR - - MODEL NUMBER PD185H42ST PD185H42STB MOWER DECK TRACTOR - - MODEL NUMBER PD185H42ST PD185H42STBSERVICE NOTES SERVICE NOTES SERVICE NOTES LIMITED WARRANTY T E C U M SEH NEW PEERLESS GEAR POWER TRAIN COMPONENTSLIMITED WARRANTIES FOR T E C U M S EHALONG ONLY RIDE UP AND DOWN HILL NOT ACROSS HILL15 DEGREES MAX FOLDFOR SERVICE OR REPLACEMENT PARTS PARTS AND SERVICE