422663, Safety Ignition KEY | Poulan PP208EPS24, 429956, 96198002701

REPAIR PARTS SNOW THROWER - MODEL NUMBER PP208EPS24 (96198002701)

BAG OF PARTS

01.14.003-B

4			KEY	PART	DESCRIPTION
	6		NO.	NO.	DESCRIPTION
5	6
5			1	198563	POWER CORD
			1	198563	POWER CORD
7	8		2	169675	RETAINER PIN
7			3	180684	WRENCH
			3	180684	WRENCH
			4	184505	REMOTE SPRING
			5	179829	SHOULDER BOLT 1/4-20
			6	191730	LOCKNUT 1/4-20
	9	10	7	72250505	CARRIAGE BOLT 5/16-18 X 5/8
	9		8	751153	LOCKNUT 5/16-18
			8	751153	LOCKNUT 5/16-18
			9	73800600	LOCKNUT 3/8-16
			10	19131316	WASHER 3/8
			11	192090	SHEAR BOLT 1/4-20 X 1-13/16
			12	73800400	LOCKNUT 1/4-20
1		12
1
	11

	KEY	PART	DESCRIPTION
	NO.	NO.	DESCRIPTION
1	1	422663	SAFETY IGNITION KEY
1

01.14.009-A

1	4
	2.56

01.14.012-A

KEY	PART	DESCRIPTION
NO.	NO.	DESCRIPTION

1180445 SHIFTER ROD TOP

2187716 SHIFTER ROD BOTTOM

372270505 CARRIAGE BOLT 5/16-18 X .75

155377

NUT 5/16-18

NOTE: All component dimensions given in U.S. inches. 1 inch = 25.4 mm

IMPORTANT: Use only Original Equipment Manufacturer (O.E.M.) replacement parts. Failure to do so could be hazardous, damage your snow thrower and void your warranty. 38

Page 38

Image 38

Poulan PP208EPS24, 429956, 96198002701 owner manual 422663, Safety Ignition KEY

Contents

Model Number Snow Thrower Safe Operation Practices for Walk-Behind Snow Throwers Table of Contents Parts Packed Separately in Carton Assembly / PRE-OPERATIONHOW to SET UP Your Snow Thrower Remove Snow Thrower from Carton Unfold Upper Handle Install Speed Control ROD See FigsInstall Traction Drive Control ROD See Figs Install Auger Control ROD See Figs Install Discharge Chute / Chute Rotator Head See Fig Install Chute Deflector Remote Control See Figs a and 8B Check Tire Pressure Primer OperationKnow Your Snow Thrower Ignition KEY Meets A.N.S.I. Safety Requirements Recoil auxiliary starter handle used for starting the engine To USE Fuel SHUT-OFF Valve See Fig HOW to USE Your Snow ThrowerStopping To USE Choke Control See Fig To Throw Snow See Fig Using the CLEAN-OUT Tool See FigPower Steering Operation See Fig To Move Forward and Backward See Fig Scraper BAR See Fig To Adjust Skid Plates See FigBefore Starting the Engine Check Engine OIL Level See Fig Before Stopping Snow Throwing TipsTo Start Engine If Recoil Starter has Frozen Before Each USE MaintenanceGeneral Recommendations Lubrication Cleaning Engine Chute Deflector Service and AdjustmentsTo Adjust Snow Thrower Height Shear Bolts See Fig To Replace Belts See Fig Carburetor To Adjust Cable Tension See FigTo Remove Wheels See Fig Engine Speed Fuel System StorageOther Engine OIL Troubleshooting Auger Assembly RH Auger HousingAuger Assembly LH KEY Part Description 23 22 Bearing Gearbox Assembly178675X008 Corner Bracket Clean OUT Tool Impeller Pulley Auger Bearing Bearing Plug Shoulder Screw Knob BlackPOP Rivet Deflector Spring Rotator Head LEVER/CABLE Rotator AssemblyCable Assembly Adjustable Rotator Pivot Bracket Washer 196944X007 Panel Bracket LH 196943X007 Panel Bracket RHHandle Grip Lower Tube Knob RED SpacerRetainer Handle Knob Shifter ROD TOP Impeller RODTraction ROD Shifter ROD Bottom Headlight Bezel Wire HarnessConsole Panel Flood Headlight Axle Shaft Sprocket Exploded Wheel HUB Speed Selector AssemblyDrive Plate Assembly END Plate Frame Cover AssemblyComplete LCT Engine 427963X428 Idler ARM Bracket Impeller BeltTraction Belt Idler Pulley Cable Bracket LH Wheel Assembly LHWheel Assembly RH Cable Bracket RH Wheel Lobe CoverWheel Driver Retainer Ring Clutch Slide Safety Ignition KEY 422663 DECAL, DANGER, Deflector 181037DECAL, Danger Limited Warranty

KEY

SHOULDER BOLT 1/4-20

WASHER 3/8

KEY

422663

SAFETY IGNITION KEY

01.14.009-A

KEY

1180445 SHIFTER ROD TOP

2187716 SHIFTER ROD BOTTOM