Poulan 96046001400, 431832 guide

SERVICE AND ADJUSTMENTS

•ATTACH MOWER SIDE SUSPENSION ARMS (A) TO CHASSIS - Position hole in arm over pin (B) on outside of tractor chassis and secure with retainer spring.

•Repeat on opposite side of tractor.

A

B

Fig. 21

•ATTACH REAR LIFT LINKS (C) - Lift rear corner of mower and position slot in link assembly over pin (D) on rear mower bracket and secure with washer and retainer spring.

C

D

Fig. 22

•ATTACH FRONT LINK (E) - Work from left side of trac- tor. Insert rod end of link assembly through front hole in tractor front suspension bracket (F).

B

A

R

C

D

PL Q

•Insert end of link (E) into hole in front mower bracket and secure with washer and retainer spring (J).

•Hook end of clutch cable spring (Q) into hole in idler arm (R).

E

FJ

H

Fig. 23

•Push clutch cable housing guide (P) into bracket.

M

Fig. 24

•Install belt on engine pulley (M), in belt keepers (G).

IMPORTANT: CHECK BELT FOR PROPER ROUTING IN ALL MOWER PULLEY GROOVES.

•Raise attachment lift lever to highest position.

MF

G

E

G

A

CD

Fig. 25

19

Image 19

Poulan 96046001400, 431832 manual Raise attachment lift lever to highest position

Contents

PXT12530 II. Slope Operation Safety RulesSafe Operation Practices for Ride-On Mowers General Operation IV. Towing ServiceGeneral Service III. Children Table of Contents Unassembled Parts Before Removing Tractor from Skid AssemblyTools Required for Assembly Toremovetractorfromcarton Check Brake System Install Seat See Fig Operation Know Your Tractor Stopping See Fig HOW to USE Your TractorAttachment Clutch Switch Disengaged Engaged To SET Parking Brake See Fig Reverse Operation System ROS See Fig To Adjust Mower Cutting Height See FigUsing the Reverse Operation System To Move Forward and Backward See Fig Before Starting the Engine To Start Engine See Fig Mowing Tips Schedule MaintenanceMaintenance General Recommendations Blade Removal See Fig BatteryTractor Blade Care Lubrication Transaxle MaintenanceEngine Belts Muffler Clean AIR ScreenCleaning AIR Filter To Install Mower See Fig Service and AdjustmentsTo Remove Mower See Fig Raise attachment lift lever to highest position To Level Mower Visual SIDE-TO-SIDE Adjustment See Fig To Check Brake Belt InstallationTo Replace Mower Blade Drive Belt See Fig To Replace Motion Drive Belt See Fig To Remove Wheel See Fig Transaxle Gear Shift Lever Neutral Adjustment See FigTo Adjust Steering Wheel Alignment To Start Engine with a Weak Battery See Fig Interlocks and Relays To Adjust Throttle Control CableTo Adjust Choke Control To Adjust Carburetor Engine OIL StorageOther Fuel System Problem Cause Correction Troubleshooting Points Excessive Only Ride UP and Down Hill Not Across Hill Degrees MAX Suggested Guide for Sighting Slopes for Safe Operation Limited Warranty