Poulan 423359, 96042003803 KNOW YOUR TRACTOR

8

KNOW YOUR TRACTOR

READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR

Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and ad just ments.

Save this manual for future reference.

Our tractors conform to the applicable safety standards of the American National Standards Institute.

FIG. 3

(A) ATTACHMENT LIFT LEVER - Used to raise and lower

the mower or other attachments mounted to your trac tor.

(B) CLUTCH/BRAKE PEDAL - Used for brak ing the

tractor and start ing the engine.

(C) PARKING BRAKE - Locks clutch/brake pedal into the

brake position.

(D) THROTTLE CONTROL - Used to control engine speed.

(E) ATTACHMENT CLUTCH LEVER - Used to engage the

mow er blades, or other at tach ments mounted to your tractor.

(F) IGNITION SWITCH - Used for starting and stopping

the engine.

(G) REVERSE OPERATION SYSTEM (ROS) "ON"

POSITION - Allows operation of mower or other powered

attachment while in reverse.

(H) LIGHT SWITCH - Turns the headlights on and off.

(J) CRUISE CONTROL LEVER - Used to set forward

move ment of tractor at desired speed without holding the

forward drive pedal.

(K) FORWARD DRIVE PEDAL - Used for forward move-

ment of tractor.

(L) REVERSE DRIVE PEDAL - Used for reverse move-

ment of tractor.

(M) FREEWHEEL CONTROL - Disengages transmission

for pushing or slowly tow ing the trac tor with the engine off.

(P) SERVICE REMINDER / HOUR METER - Indicates

when service is required for the engine and mower.

A

D

B

C

HG

J

E

M

K

L

P

F

OPERATION

Contents

Main MODEL: PB22H46YT SAFETY RULES Safe Operation Practices for Ride-On Mowers I. GENERAL OPERATION WARNING II. SLOPE OPERATION SAFETY RULES Safe Operation Practices for Ride-On Mowers III. CHILDREN IV. TOWING V. SERVICE TABLE OF CONTENTS PRODUCT SPECIFICATIONS CUSTOMER RESPONSIBILITIES Slope Sheet Key ASSEMBLY UNASSEMBLED PARTS TO REMOVE TRACTOR FROM CARTON UNPACK CARTON BEFORE REMOVING TRACTOR FROM SKID ASSEMBLY CHECK TIRE PRESSURE CHECK DECK LEVELNESS CHECK FOR PROPER POSITION OF ALL BELTS CHECK BRAKE SYSTEM Page KNOW YOUR TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR HOW TO USE YOUR TRAC TOR TO SET PARKING BRAKE (See Fig. 4) D F B C TO MOVE FORWARD AND BACKWARD (See Fig. 7) TO USE CRUISE CONTROL (J) (See Fig. 7) S J K L TO OPERATE MOWER REVERSE OPERATION SYSTEM (ROS) TO OPERATE ON HILLS TO TRANSPORT (See Fig. 12) TOWING CARTS AND OTHER AT TACH MENTS BEFORE STARTING THE ENGINE CHECK ENGINE OIL LEVEL TO START ENGINE (See Fig. 3) PURGE TRANSMISSION MOWING TIPS T R A C T 0 R E N G I N E SPINDLE ZERK GENERAL RECOMMENDATIONS BEFORE EACH USE TRACTOR BLADE CARE BATTERY BLADE REMOVAL (See Fig. 15) TRANSAXLE MAINTENANCE TRANSAXLE PUMP FLUID V-BELTS LUBRICATION DECK WASHOUT PORT (See Fig. 16) CLEANING ENGINE COOLING SYSTEM E F D L P Page TO LEVEL MOWER TO REPLACE MOWER BLADE DRIVE BELT (See Fig. 29) TO CHECK BRAKE TO REPLACE MOTION DRIVE BELT (See Fig. 30) TO AD JUST STEER ING WHEEL ALIGN MENT FRONT WHEEL TOE-IN/CAMBER TO REMOVE WHEEL FOR REPAIRS (See Fig. 31) TO START ENGINE WITH A WEAK BATTERY (See Fig. 32) REPLACING BATTERY (See Fig. 33) TRANSMISSION REMOVAL/RE PLACE MENT TO AD JUST THROTTLE CON TROL CABLE TO AD JUST CHOKE CON TROL TO ADJUST CARBURETOR STORAGE TRACTOR BATTERY FUEL SYSTEM ENGINE OIL TROUBLESHOOTING PROBLEM CAUSE CORRECTION Will not start Hard to start Engine will not turn over Engine clicks but will not start TROUBLESHOOTING LIMITED WARRANTY Page SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION PARTS AND SERVICE NOTE: LENTRETIEN ET LES PICES DE RE CHANGE Page Page GARANTIE LIMITE GUIDE DE DPANNAGE PROBLME CAUSE CORRECTION GUIDE DE DPANNAGE Le moteur manque mais le moteur ne II y a un dclic Moteur ne tourne ENTREPOSAGE INFORMATION SUPPLMENTAIRE CYLINDRE(S) BATTERIE HUILE DE MOTEUR TRANS MIS SION POUR REMPLACER LE FUSIBLE POUR RGLER LE CARBURATEUR POUR RGLER LA COMMANDE DU STARTER DES GAZ 22 Fig. 32 PA RA TIONS (Voir la Fig. 31) BAT TE RIE FAIBLE (Voir la Fig. 32) POUR DMARRER LE MOTEUR AVEC UNE 21 POUR VRIFIER LES FREINS INSTALLATION DE LA COURROIE - RETIRER LA COURROIE DENTRANEMENT (Voir la Fig. 30) 20 FIG. 25 AJUSTEMENT AVANT/ARRIRE (Voir les Figs. 27 et 28 FIG. 27 POUR AJUSTER LE NIVEAU LA TONDEUSE Page 18 SIONS OU RGLAGES. ADVERTISSEMENT: POUR VITER DES DOMMAGES SRIEUX, AVANT DE FAIRE TOUS LES RVI- E F (Voir Fig. 19) POUR ENLEVER LA TONDEUSE niveau et actionnez le frein de stationnement. Assurez-vous que le tracteur se trouve sur une surface de 17 SYSTME DE VENTILATION (Voir la Fig. 17) POUR CHANGER LHUILE DE MOTEUR NETTOYAGE 16 FILTRE DHUILE DE MOTEUR LUBRIFICATION COURROIES TRAPZODALES 15 ENTRETIEN DES LAMES POUR NETTOYER LA BATTERIE ET LES BORNES: BATTERIE ENLEVER LA LAME (Voir la Fig. 15) CONSEILS DE TONTE PURGER LA TRANSMISSION FIG. 13 12 TI QUE AVANT DE DMARRER LE MOTEUR 11 AUTRES ACCESSOIRES EN MARCHE ARRIRE UTILISATION DU SYSTME DE FONCTIONNEMENT 10 CARACTRISTIQUES DU SYSTME (Voir la Fig. 9) POUR RGLER LES ROUES DE JAUGE L COMMENT UTILISER VOTRE TRAC TEUR B C STA TION NE MENT (Voir la Fig. 4) POUR EMBRAYE LE FREIN DE Fig. 4 CONNAISSEZ VOTRE TRACTEUR Page 6 TRAC TEUR, FAITES ATTENTION AU: PENDANT QUE VOUS APPRENEZ UTILISER VO TRE VRIFIER LE SYSTME DE FREIN PICES NON MONTES SOMMAIRE RESPONSABILITS DU CLIENT SPCIFICATIONS DE PRODUIT 3 MANIPULATION SRE DE LESSENCE RGLES DE SCURIT 2 I. FONCTIONNEMENT GNRAL II. FONCTIONNEMENT DANS LES PENTES AVERTISSEMENT: Conseils pour lutilisation en toute scurit des tracteurs PB22H46YT MODLE: