Manuals
/
Reliance Water Heaters
/
Household Appliance
/
Water Heater
Reliance Water Heaters
196296-001, 606 Series instruction manual Lindahl Parkway Ashland City, TN
Models:
606 Series
196296-001
1
32
32
Download
32 pages
14.58 Kb
25
26
27
28
29
30
31
32
<
>
Troubleshooting
Install
Repair Parts List
Drain Valve Washer Replacement
Warranty
Maintenance
Claim Procedure
Burner Cleaning
Temperature-Pressure
How to
Page 32
Image 32
500 Lindahl Parkway Ashland City, TN 37015
www.reliancewaterheaters.com
32
Page 31
Page 32
Image 32
Page 31
Contents
NOT FOR USE IN MANUFACTURED MOBILE HOMES
For Your Safety
RESIDENTIAL GAS WATER HEATERS
IMPORTANT DEFINITIONS
SAFE INSTALLATION, USE AND SERVICE
DANGER
GENERAL SAFETY
TABLE OF CONTENTS
INTRODUCTION
PREPARING FOR THE NEW INSTALLATION
TO INSTALLOR OPERATE THE WATER HEATER
TYPICAL INSTALLATION
GET TO KNOW YOUR WATER HEATER - GAS MODELS
TEMPERATURE-PRESSURE
T THERMOSTAT V PILOT & MAIN BURNER - NATURAL GAS
MIXING VALVE USAGE
TYPICAL INSTALLATION
REMOVING THE OLD WATER HEATER
MATERIALS AND BASIC TOOLS NEEDED
DECIDING ON THE TYPE OF INSTALLATION
Section A Galvanized Piping
Section B Copper Sweat Piping
LOCATING THE NEW WATER HEATER
FACTS TO CONSIDER ABOUT THE LOCATION
INSULATION BLANKETS
B. ALL AIR FROM OUTDOORS See Figures 12, 13 and
3.When communicating with the outdoors through horizontal ducts, each opening shall have a minimum free area of 1 square inch per 2,000 Btu per hour 11 cm2/kW of total input rating of all equipment in the enclosure, see Figure
INSTALLING THE NEW WATER HEATER
SECTION A - GALVANIZED PIPING
SECTION B COPPER SWEAT PIPING
Page
TEMPERATURE-PRESSURERELIEF VALVE
FILLING THE WATER HEATER
VENTING
GAS PIPING
FIGURE 29. GAS PIPING WITH FLEXIBLE CONNECTOR
SEDIMENT TRAPS
FIGURE 30. GAS PIPING WITH ALL
BLACK IRON PIPE TO GAS CONTROL
FOR YOUR SAFETY READ BEFORE LIGHTING
LIGHTING INSTRUCTIONS
TO TURN OFF GAS TO APPLIANCE
WHAT TO DO IF YOU SMELL GAS
FOR YOUR SAFETY READ BEFORE LIGHTING
LIGHTING INSTRUCTIONS
TO TURN OFF GAS TO APPLIANCE
WHAT TO DO IF YOU SMELL GAS
TEMPERATURE REGULATION
FOR YOUR INFORMATION
START UP CONDITIONS
DRAFT HOOD OPERATION
SMOKE / ODOR
THERMAL EXPANSION
STRANGE SOUNDS
SMELLY WATER
PERIODIC MAINTENANCE
HIGH WATER TEMPERATURE SHUT OFF SYSTEM
VENTING SYSTEM INSPECTION
BURNER INSPECTION
BURNER CLEANING
TEMPERATURE-PRESSURE RELIEF VALVE OPERATION
HOUSEKEEPING
ANODE ROD INSPECTION
See Figure
DRAIN VALVE WASHER REPLACEMENT
SERVICE
LEAKAGE CHECKPOINTS
TROUBLESHOOTING GUIDELINES
Problem
Solution
Cause
REPAIR PARTS LIST
Flue Baffle Assembly
Cleanout Cover optional
Cleanout Gasket optional
RESIDENTIAL GAS WARRANTY
SERVICE AND LABOR RESPONSIBILITY
MODEL SERIES
Tank
CLAIM PROCEDURE
INSTALLATION INFORMATION
LIMITATION ON IMPLIED WARRANTIES
DISCLAIMERS
500 Lindahl Parkway Ashland City, TN
