Poulan 194993 manual To Replace Fuse, To Adjust Throttle Control Cable, To Adjust Choke Control

Page 23

SERVICE AND ADJUSTMENTS

REPLACING BATTERY (See Fig. 25)

WARNING: Do not short battery terminals by allowing a wrench or any other object to contact both terminals at the same time. Before connect- ing battery, remove metal bracelets, wristwatch bands, rings, etc.

Positive terminal must be connected first to prevent sparking from acci- dental grounding.

•Lift hood to raised position.

•Remove terminal guard.

•Disconnect BLACK battery cable then RED battery cable and carefully remove battery from tractor.

•Install new battery with terminals in same position as old battery.

•Reinstall terminal guard.

•First connect RED battery cable to positive (+) battery terminal with hex bolt and keps nut as shown. Tighten securely.

•Connect BLACK grounding cable to negative (-) battery terminal with remaining hex bolt and keps nut. Tighten securely

•Close terminal access doors.

•Close hood.

TO REPLACE FUSE

Replace with 20 amp automotive-type plug-in fuse. The fuse holder is located behind the dash.

TO REMOVE HOOD AND GRILL ASSEMBLY (See Fig. 26)

•Raise hood.

•Unsnap headlight wire connector.

•Stand in front of tractor. Grasp hood at sides, tilt toward engine and lift off of tractor.

•To replace, reverse above procedure.

HOOD

HEADLIGHT WIRE

CONNECTOR

02141

FIG. 26

ENGINE

TERMINAL ACCESS DOOR

KEPS NUT

HEX BOLT

POSITIVE (RED)

CABLE

TO ADJUST THROTTLE CONTROL CABLE

The throttle control has been preset at the factory and adjustment should not be necessary. If adjustment is nec- essary, see engine manual.

TO ADJUST CHOKE CONTROL

The choke control has been preset at the factory and ad- justment should not be necessary. If adjustment is neces-

TERMINAL GUARD

NEGATIVE (BLACK)

CABLE

sary, see engne manual.

TO ADJUST CARBURETOR

Your carburetor is not adjustable. If your engine does not

FIG. 25

TO REPLACE HEADLIGHT BULB

•Raise hood.

•Pull bulb holder out of the hole in the backside of the grill.

•Replace bulb in holder and push bulb holder securely back into the hole in the backside of the grill.

•Close hood.

INTERLOCKS AND RELAYS

Loose or damaged wiring may cause your tractor to run poorly, stop running, or prevent it from starting.

•Check wiring. See electrical wiring diagram in the Repair Parts section.

operate properly due to suspected carburetor problems, take your tractor to an authorized service center for repair and/or adjustment.

23

Page 22 Page 24
Image 23
Page 22 Page 24
Contents Always Wear EYE Protection During Operation DB18542YTII. Slope Operation Safety RulesSafe Operation Practices for Ride-On Mowers General OperationIV. Towing ServiceIII. Children Table of Contents Contents of Hardware Pack Before Removing Tractor from Skid AssemblyTools Required for Assembly To Remove Tractor from CartonCheck Battery See Fig Check Brake System Check Tire PressureCheck Deck Levelness Check for Proper Position of ALL BeltsOperation Know Your Tractor HOW to USE Your Tractor To Operate Mower See Fig To Adjust Gauge Wheels See FigReverse Operation System ROS Before Starting the Engine Mowing Tips Before Each USE MaintenanceLubrication Chart General RecommendationsCheck Operator Presence System TractorBlade Removal See Fig To Sharpen Blade See FigTransaxle Cooling BatteryEngine BeltsCleaning To Remove Mower See Fig Service and AdjustmentsTo Install Mower See Fig Belt Removal To Level Mower HousingBelt Installation To Replace Mower Blade Drive Belt See FigTo Check Brake To Check and Adjust Brake See FigTo Adjust Brake To Replace Motion Drive Belt See FigFront Wheel TOE-IN/CAMBER Transaxle Gear Shift Lever NEUTRAL- Adjustment See FigTo Adjust Steering Wheel ALIGN- Ment To Start Engine with a Weak Battery See FigTo Replace Fuse To Adjust Throttle Control CableTo Adjust Choke Control To Adjust CarburetorEngine OIL StorageOther Fuel SystemTroubleshooting Points Engine dies when Limited Warranty Policy Only Ride UP and Down Hill Not Across Hill Degrees MAX Suggested Guide for Sighting Slopes for Safe OperationParts and Service

194993 specifications

The Poulan 194993 is a noteworthy string trimmer designed to provide efficiency and durability for both residential and commercial users. Offering a blend of power and innovative features, this trimmer is a great choice for those looking to maintain their lawns and gardens with precision.

One of the defining characteristics of the Poulan 194993 is its powerful engine. It is equipped with a 25cc two-cycle engine, which provides ample power to tackle tough weeds and grass while ensuring a lightweight, easy-to-maneuver design. This combination makes it suitable for various tasks, from trimming delicate flower beds to clearing overgrown areas.

A standout feature of the Poulan 194993 is its Smart Start technology, which allows for easy starting with minimal effort. This technology reduces the resistance in the starter cord by up to 40%, making it possible for users to start the engine quickly and effortlessly, even after extended periods of storage. This feature is particularly helpful for those who may struggle with traditional pull-start trimmers.

The trimmer also boasts a dual-line feed system, which enhances cutting efficiency. The dual-line design allows for a wider cutting path, significantly reducing the time spent on trimming tasks. The semi-automatic feed spool makes it easy to advance the line, ensuring a consistent cutting performance without the need for manual adjustments.

Ergonomically designed, the Poulan 194993 ensures user comfort during operation. It features an adjustable handle that can be customized to suit individual preferences, reducing fatigue during prolonged use. The lightweight construction further complements its ease of handling, making it an ideal choice for long days of yard work.

In addition, this trimmer incorporates a durable construction that withstands the rigors of regular use. The rugged materials used in its design ensure longevity, making it a reliable option for homeowners and professionals alike.

Overall, the Poulan 194993 offers a well-rounded solution for those looking for an effective and user-friendly string trimmer. With its powerful engine, innovative features, and ergonomic design, it stands out as a top choice for maintaining vibrant and well-groomed outdoor spaces. Whether tackling everyday grass trimming or handling more challenging jobs, the Poulan 194993 proves to be a valuable addition to any gardening toolkit.
Top Page Image Contents