Poulan PB195H46YTX, 96042006800, 418771 manual Table of Contents

Page 4

PRODUCT SPECIFICATIONS

Gasoline Capacity

2.50 Gallons

 

and type:

Unleaded Regular

Oil Type (API-SG-SL):

SAE 10W30 (above 32°F)

 

SAE 5W-30 (below 32°F)

Oil Capacity:

W/ Filter:

56 oz.

 

W/O Filter:

48 oz.

Spark Plug:

Champion RC12YC

 

(Gap: .030")

 

Ground Speed (MPH):

Forward:

0 – 5.5

 

Reverse:

0 – 2.4

Charging System:

3 Amps Battery

 

5 Amps Headlights

Battery:

AMP/HR:

28

 

MIN. CCA:

230

 

Case Size:

U1R

Blade Bolt Torque:

45-55 FT. LBS.

 

 

 

CONGRATULATIONS on your purchase of a new tractor. It has been designed, engineered and manufactured to give you the best possible dependability and performance.

Should you experience any problem you cannot easily rem- edy, please contact your nearest authorized servicecenter/ department We have competent, well-trained technicians and the proper tools to service or repair this tractor.

Please read and retain this manual. The instructions will enable you to assemble and maintain your tractor properly. Always observe the “SAFETY RULES”.

CUSTOMER RESPONSIBILITIES

•Read and observe the safety rules.

•Follow a regular schedule in maintaining, caring for and using your tractor.

•Follow the instructions under “Maintenance” and “Stor- age” sections of this owner’s manual.

WARNING: This tractor is equipped with an internal com- bustion engine and should not be used on or near any unimprovedforest-covered,brush-coveredorgrass-covered land unless the engine’s exhaust system is equipped with a spark arrester meeting applicable local or state laws (if any). If a spark arrester is used, it should be maintained in effective working order by the operator.

In the state of California the above is required by law (Section 4442 of the California Public Resources Code). Other states may have similar laws. Federal laws apply on federal lands.

A spark arrester for the muffler is available through your nearest authorized service center/department (See REPAIR PARTS section of this manual).

TABLE OF CONTENTS

SAFETY RULES

2

PRODUCT SPECIFICATIONS

4

CUSTOMER RESPONSIBILITIES

4

ASSEMBLY

5

OPERATION

7

MAINTENANCE SCHEDULE

14

MAINTENANCE

14

SERVICE AND ADJUSTMENTS

18

STORAGE

24

TROUBLESHOOTING

25

WARRANTY

28

4

Page 3 Page 5
Image 4
Page 3 Page 5
Contents PB195H46YTX ModelSafety Rules Safe Operation Practices for Ride-On MowersGeneral Operation II. Slope OperationService General ServiceIII. Children IV. TowingTable of Contents Assembly Unassembled PartsTo Remove Tractor from Carton Unpack CartonCheck Tire Pressure Check Deck LevelnessCheck for Proper Position of ALL Belts Check Brake SystemOperation Know Your Tractor DHEHOW to USE Your Tractor To Adjust Mower Cutting Height See Fig To Adjust Gauge Wheels See FigSystem Characteristics To Operate Mower See FigBefore Starting the Engine Reverse Operation System ROSTo Operate on Hills To Transport See FigsADD Gasoline To Start Engine See FigPurge Transmission Automatic Transmission Warm UPMowing Tips Maintenance MaintenanceGeneral Recommendations ScheduleBattery TractorBrake Operation TiresEngine Cleaning Engine OIL FilterMuffler Spark PlugsService and Adjustments To Install Mower See -21To Remove Mower See Fig Lower DashInstall belt on engine pulley M, in belt keepers G To Level Mower Turn nut right Turn nut left To raise mower To lower mowerTo Check Brake To Replace Mower Drive Belt See FigTo Replace Motion Drive Belt See Fig To Start Engine with a Weak Battery See Fig Replacing Battery See FigFront Wheel TOE-IN/CAMBER To Remove Wheel for Repairs See FigTo Adjust Throttle Control Cable To Adjust Choke ControlTo Adjust Carburetor To Replace Headlight BulbStorage OtherFuel System Engine OILTroubleshooting Points Problem Cause CorrectionEngine dies when Suggested Guide for Sighting Slopes for Safe Operation Outdoor Products Customer Service Dept HOPCanada contact Stevens Creek Road Terry Fox Way Augusta, GA 30907 USAService Notes Parts and Service Changere DE Pièces LES ET L’ENTRETIEN Dentretien Remarques Dept Service Customer Products Outdoor Canada Au AutoriséGarantie cette de exclus sont normal l’entretien et Initiale d’achat date la de compter à jours 90 dixDegrés Suivant LES UNE Pliez EST CeciDépannage DE Guide Correction Cause ProblèmeLame de mandrin le Remplacez Tordu est lame de mandrin Un Moteur EntreposageTracteur Starter DU Commande LA Régler Pour GAZ DES Commande LA DE Câble LE Régler PourReglages ET Revision MoteurFig la Voir Tionsraparé LES Pour Roues LES Enlever Pour Fig la Voir Batterie LA ReplacerAvant Roue LA DE PINCEMENT/CARROSSAGE Réglages ET Révision Fig la Voir D’ENTRAÎNEMENT Courroie a L Acer Rempl PourFreins LES Vérifier Pour 27 .FIGTondeuse LA Niveau LE Ajuster Pour 25 .FIG24 .FIG 23 .FIG21 .FIG 19 .FIG 20 .FIG18 .FIG Coin le Soulevez C Arrières Bielles LES AttachezCourroie LA ET Tondeuse LA Installer Fig VoirTondeuse LA Enlever Pour 17 .FIGEntretien Fig la Voir’ALLUMAGE Bougie Moteur DE D’HUILE FiltreAIR À Filtre ’AIR Tamis LE NettoyerSionmistrans LA DE Moteur Fluide Transmission LA DE RefroidissementFig la Voir Lame LA Enlever EN Fonctionnement DE Système ETRecommandations LES GénéralesLubrification DE Tableau Utilisation Chaque AvantTondre DE Conseils Utilisation12 .FIG Transmission LA Purger Moteur LE Démarrer PourQuetimaauto Sion Transmis DE Réchauffement11 et 3 .Fig les Voir Moteur LE Démarrer DE AvantMAR EN Fonctionnement DE Système FiglaVoirTONDEUSELAUTILISERPOUR Jauge DE Roues LES Régler Pour10 .FIG Système DU CaractéristiquesGAZ DES Commande LA Utiliser Pour VitessDE Régulateur LE Utiliser Comment Fig la Voir Mentnetionsta DE Frein LE Engager PourUtilisation ’EMBRAYAGE Montage NI DE EST Tondeuse LA SI VérifierPA LA DE Tracteur LE Retirer Pour PAL LA DE Tracteur LE Retirer PourMontées NON Piéces Toncar DU Tracteur LE Sortir PourFig la Voir Batterie LA Vérifier Fig la Voir Siège LE AjustezClient DU Responsabilités SommaireProduit DE Spécifications Entretien RemorquageEnfants Général EntretienPentes LES Dans FonctionnementGénéral Fonctionnement Tracteurs des sécurité toute en l’utilisation pour ConseilsAUX Imprimé Avertissement

418771, PB195H46YTX, 96042006800 specifications

The Poulan 96042006800, commonly recognized as the PB195H46YTX lawn tractor, is engineered for homeowners who prioritize efficiency and performance in maintaining their yards. This robust machine boasts a powerful 19.5 HP Briggs & Stratton engine, which offers reliable starting and consistent power delivery. With its robust build and advanced features, the PB195H46YTX is perfect for tackling large lawns and uneven terrains with ease.

One of the standout features of the PB195H46YTX is its 46-inch cutting deck, which allows for a wider cutting swath, reducing the time spent mowing. The deck is designed with a durable material and a reinforced edge, ensuring it withstands the rigors of regular usage while providing a clean and precise cut. Additionally, the tractor offers adjustable cutting heights, enabling users to customize the grass length according to their preferences and the seasonal needs of their lawn.

The transmission system of the PB195H46YTX employs an easy-to-use hydrostatic drive, which offers seamless speed control without the need for manual gear shifting. This feature simplifies operation, allowing users to focus more on steering and mowing rather than constantly adjusting speed. The tractor also features a tight turning radius, making it adept at navigating around obstacles like trees and flower beds.

Comfort and convenience are also vital components of the PB195H46YTX’s design. It comes equipped with a plush, high-back seat with adjustable settings, allowing users to find their optimal position during longer mowing sessions. The ergonomically designed steering wheel and controls are positioned for easy access, minimizing strain and fatigue.

Incorporating advanced technologies, this lawn tractor is built with a durable frame and advanced cutting system, ensuring longevity and high performance. The unit is compatible with various accessories, including baggers and mulchers, making it a versatile option for year-round yard maintenance.

Overall, the Poulan 96042006800, PB195H46YTX, and its associated model number 418771 combine power, comfort, and functionality to provide an exceptional mowing experience. Its features make it a smart choice for homeowners committed to achieving a well-kept lawn without sacrificing their time or effort.
Top Page Image Contents