Poulan PO165H42C owner manual KEY Part Description

Page 31

REPAIR PARTS

TRACTOR - - MODEL NUMBER PO165H42C

CHASSIS AND ENCLOSURES

KEY	PART
NO.	NO.	DESCRIPTION
1	174620	Chassis
2	176554	Drawbar
3	17060612	Screw 3/8-16 x 3/4
5	155272	Bumper Hood/Dash
6	155923	Saddle Flat Lt
8	155138	Clip Retainer Slide-On

9168348X012 Dash

1072140608 Bolt RdHd Sqnk. 3/8-16 Unc x 1

11155927 Panel Asm. Dash Lh

12	145660	Clip Tinnerman Grile P/L
13	172107X010	Panel Dash Rh

1574180512 Screw Mach Trhd 5/16-18 Unc x 3/4

1673510500 Nut Keps 5/16-18 Unc

17159639X428 Hood

18126938X Bumper Hood

2474780616 Bolt Fin Hex 3/8-16 Unc x 1 Gr. 5

2519131312 Washer 13/32 x 13/16 x 12 Ga.

2673800600 Nut Lock Hex w/Insert 3/8-16 UNC

28 140434

Grill/Lens Asm

29140273X599 Lens Grille Private label

30169467X428 Fender Asm

31

136619

Bracket Fender

33145244X428 Footrest

34145243X428 Footrest

3572110606 Bolt RdHd Sht. Sqnk. 3/8-16 x 3/4

3717490508 Screw Thdrol 5/16-18 x 1/2 Tyt

38175710 Bracket Asm. Pivot Mower Rear

5173800400 Nut Lock Hex W/Ins. 1/4-20

5219091416 Washer 9/32 x 7/8 x 16 Ga.

53	144697	Bracket Grille LH
54	161464	Screw Hex Wshd 8-18 x 7/8
55	144696	Bracket, Grille RH

5774780412 Bolt Fin Hex 1/4-20 x .75

58150127 Air Duct Private Label

145	156524	Rod Pivot Chassis/Hood
205	17490608	Screw Thdrol 3/8-16 x 1/2
206	170165	Bolt shoulder 5/16-18

20817670608 Screw Thdrol 3/8-16 x 1/2

20917000612 Screw Hex Wsh Thdrol 3/8-16

212	156229	Insert Lens Reflector
- -	5479J	Plug Btn Blk

NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm

31

Image 31

Contents Model NO. PO165H42C II. Slope Operation IV. ServiceSafe Operation Practices for Ride-On Mowers General OperationTable of Contents Customer Responsibilities Product SpecificationsSlope Sheet Unassembled PartsSteering Wheel Seat KeyTo Remove Tractor from Carton AssemblyTools Required for Assembly HOW to SET UP Your TractorLower seat into operating position and sit on seat Install Seat See FigCheck Brake System Check Tire PressureCheck Deck Levelness Check for Proper Position of ALL BeltsOperation Know Your Tractor HOW to USE Your Tractor To Transport See Figs To Adjust Gauge Wheels See FigTo Operate Mower See Fig To Operate on HillsTo Start Engine See Fig Before Starting the EngineCheck Engine OIL Level ADD GasolineMowing Tips General Recommendations Customer ResponsibilitiesBefore Each USE Tractor Engine Muffler CleaningSpark Plugs To Remove Mower See Fig Service and AdjustmentsTo Level Mower Housing To Install Mower See FigBelt Removal To Adjust Brake See FigBelt Installation To Replace Mower Blade Drive Belt See FigTo Replace Motion Drive Belt See Fig Transaxle Motion Control Lever Neutral Adjustment See FigTransmission REMOVAL/REPLACEMENT To Adjust Steering Wheel AlignmentTo Attach Jumper Cables To Start Engine with a Weak Battery See FigReplacing Battery See Figs To Remove Wheel for Repairs See FigTo Replace Fuse To Adjust CarburetorTo Replace Headlight Bulb Interlocks and RelaysEngine OIL StorageOther Fuel SystemTroubleshooting Points OFF Tractor - Model Number PO165H42C Schematic Electrical KEY Part NO. NO. Description Chassis and Enclosures KEY Part Description Drive Repair Parts Steering Assembly KEY Part NO. NO. Description Engine KEY Part Description Seat Assembly Wheels & Tires DecalsMower Lift Nut Lock w/Wsh 1/2-13 Unc Mower Deck Repair Parts Service Notes Service Notes Limited Warranty Only Ride UP and Down Hill Suggested Guide for Sighting Slopes for Safe Operation