Poulan owner manual Tractor - Model Number PDB18H42STA, Schematic

Page 29

REPAIR PARTS

TRACTOR - - MODEL NUMBER PDB18H42STA

SCHEMATIC

RED

BLACK

A

RED

BATTERY

RED	M
	M
FUSE

AMMETER (OPTIONAL)

WHITE

	RED	B	S
		B	M
		G	A1
		L	A2
	BLACK	IGNITION
	BLACK	SWITCH
		SWITCH

ORANGE

BLUE

				STARTER
				BLACK
			SOLENOID
	CLUTCH / BRAKE
	(PEDAL UP)		WHITE
			WHITE
				SEAT SWITCH
				(NOT OCCUPIED)
		WHITE
	BLACK		BLACK	BLACK
			BLACK	BLACK
	BLACK		ATT'MENT CLUTCH
			ATT'MENT CLUTCH	GROUNDING
		BLACK	(CLUTCH OFF)	GROUNDING
	HOUR	BLACK	(CLUTCH OFF)	CONNECTOR
	HOUR			CONNECTOR
	METER
	(OPTIONAL)			SPARK
		BLACK	IGNITION	PLUG
			UNIT	GAP
			UNIT	(2 PLUGS ON
	FUEL			(2 PLUGS ON
	FUEL			TWIN CYL. ENGINES)
	LINE
			CHARGING SYSTEM OUTPUT	28 VOLTS AC @ 3600 RPM
			9 AMP DC @ 3600 RPM	(REGULATOR DISCONNECTED)
	FUEL SHUT-OFF	RED
	SOLENOID	RED	REGULATOR
	SOLENOID		REGULATOR
	(IF SO EQUIPPED)			ALTERNATOR
				ALTERNATOR

IGNITION SWITCH

POSITION	CIRCUIT	“MAKE”


OFF	M+G+A1	NONE
RUN/LIGHT	B+A1	A2+L
RUN	B+A1	NONE
START	B + S + A1	NONE

BROWN BLACK

	NON-REMOVABLE	HEADLIGHTS
	CONNECTIONS	HEADLIGHTS
	CONNECTIONS

REMOVABLE

CONNECTIONS

WIRING INSULATED CLIPS

NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE REPLACED TO PROPERLY SECURE YOUR WIRING.

29

Image 29

Contents PDB18H42STA Safety Rules Safety Rules Table of Contents Steering Wheel Seat Unassembled PartsGauge Wheel Slope SheetTools Required for Assembly AssemblyHOW to SET UP Your Tractor To Remove Tractor from CAR- TONAssemble Gauge Wheels to Mower Deck See a Check Battery See FigTo Convert to Bagging or Discharging To SET UP Your Mower for MulchingCheck Tire Pressure Check Deck LevelnessOperation Know Your Tractor HOW to USE Your Tractor To Operate Mower See Fig To Adjust Gauge Wheels See FigTo Operate on Hills To Transport See FigsTowing Carts and Other ATTACH- Ments Before Starting the EngineCheck Engine OIL Level ADD GasolineAutomatic Transmission Warm UP Mowing TipsPurge Transmission Mulching Mowing Tips Lubrication Chart MaintenanceGeneral Recommendations Before Each USETractor Engine Engine OIL Filter CleaningMuffler Spark PlugsTo Remove Mower See Fig Service and AdjustmentsTo Install Mower See Fig FRONT-TO-BACK Adjustment See Figs To Level Mower HousingTo Replace Motion Drive Belt See Fig To Check and Adjust Brake See FigTo Replace Mower Blade Drive Belt See Fig Transaxle Motion Control Lever Neutral Adjustment See Fig Transmission REMOVAL/REPLACEMENTTo Adjust Steering Wheel Alignment Front Wheel TOE-IN/CAMBERReplacing Battery See Figs To Start Engine with a Weak Battery See FigTo Attach Jumper Cables To Remove CABLES, Reverse OrderTo Replace Headlight Bulb To Adjust CarburetorInterlocks and Relays To Replace FuseOther StorageFuel System Engine OILTroubleshooting Points OFF Tractor - Model Number PDB18H42STA SchematicTractor - Model Number PDB18H42STA Electrical KEY Part NO. NO. Description Tractor - Model Number PDB18H42STA Chassis and Enclosures KEY Part Description Tractor - Model Number PDB18H42STA Drive Repair Parts Tractor - Model Number PDB18H42STA Steering Assembly 180656 Wheel Steering Tractor - Model Number PDB18H42STA Engine KEY Part NO. NO. Description Tractor - Model Number PDB18H42STA Seat Assembly Wheels & Tires Tractor - Model Number PDB18H42STA DecalsTractor - Model Number PDB18H42STA Mower Lift Repair Parts Tractor - Model Number PDB18H42STA Mower Deck 182032X421 Limited Warranty Only Ride UP and Down Hill Not Across Hill Degrees MAX Suggested Guide for Sighting Slopes for Safe OperationParts and Service