Poulan 96042011300, 432448 manual To Replace Headlight Bulb, Interlocks and Relays, To Replace Fuse

Page 22

SERVICE AND ADJUSTMENTS

Lift seat pan to raised position.

Disconnect BLACK battery cable first then RED battery cable and carefully remove battery from tractor.

Install new battery with terminals in same position as old battery.

First connect RED battery cable to positive (+) terminal with bolt and nut as shown. Tighten securely. Slide terminal cover over terminal.

Connect BLACK grounding cable to negative (-) ter- minal with remaining bolt and nut. Tighten securely.

Lower seat pan.

SEAT PAN

 

TERMINAL

NUT

COVER

BOLT

 

POSITIVE

NEGATIVE

(RED)

(BLACK)

CABLE

CABLE

02603

 

Fig. 34

TO REPLACE HEADLIGHT BULB

Raise hood.

Pull bulb holder out of the hole in the backside of the grill.

Replace bulb in holder and push bulb holder securely back into the hole in the backside of the grill.

Close hood.

INTERLOCKS AND RELAYS

Loose or damaged wiring may cause your tractor to run poorly, stop running, or prevent it from starting.

Check wiring. See electrical wiring diagram in the Repair Parts section.

TO REPLACE FUSE

Replace with 20 amp automotive-type plug-in fuse. The fuse holder is located behind the dash.

TO REMOVE HOOD AND GRILL ASSEMBLY (See Fig. 35)

Raise hood.

Unsnap headlight wire connector.

Stand in front of tractor. Grasp hood at sides, tilt toward engine and lift off of tractor.

To replace, reverse above procedure.

HOOD

HEADLIGHT WIRE

CONNECTOR

03075

FIG. 35

ENGINE

TO ADJUST THROTTLE CONTROL CABLE

The throttle control has been preset at the factory and adjustment should not be necessary. If adjustment is nec- essary, see engine manual.

TO ADJUST CHOKE CONTROL

The choke control has been preset at the factory and ad- justment should not be necessary. If adjustment is neces- sary, see engine manual.

TO ADJUST CARBURETOR

Your carburetor is not adjustable. If your engine does not operate properly due to suspected carburetor problems, take your tractor to an authorized service center for repair and/or adjustment.

22

Image 22
Contents PB19546LT ModelGeneral Operation Safety RulesSafe Operation Practices for Ride-On Mowers II. Slope OperationIII. Children ServiceIV. Towing Table of Contents Unassembled Parts AssemblyTools Required for Assembly ToremovetractorfromcartonCheck for Proper Position of ALL Belts Check Tire PressureCheck Deck Levelness Check Brake SystemOperation Know Your Tractor Stopping See Figs HOW to USE Your TractorTo SET Parking Brake See Fig To USE Throttle Control D See FigTo Adjust Gauge Wheels See Fig To Adjust Mower Cutting Height See FigReverse Operation System ROS See Fig Before Starting the Engine Mowing Tips To Start Engine See FigGeneral Recommendations MaintenanceMaintenance ScheduleBlade Removal See Fig BatteryTractor Check Operator Presence SystemBelts Transaxle MaintenanceEngine LubricationCleaning To Install Mower See Fig Service and AdjustmentsTo Remove Mower See Fig Install belt on engine pulley M, in belt keepers G To Level Mower Turn nut right Turn nut left To raise mower To lower mowerTo Check Brake Transaxle Gear Shift Lever NEUTRAL- Adjustment See FigTo Replace Mower Blade Drive Belt See Fig To Replace Motion Belt Drive See FigFront Wheel TOE-IN/CAMBER To Start Engine with a Weak Battery See FigReplacing Battery See Fig To Remove Wheel for Repairs See FigTo Adjust Carburetor To Adjust Throttle Control CableTo Adjust Choke Control To Replace Headlight BulbFuel System StorageOther Engine OILTroubleshooting Points Troubleshooting Only Ride UP and Down Hill Not Across Hill Degrees MAX Fold Alon THI Dotted Line REE LopeDegrés MAX Dépannage DE Guide Moteur le quand ieuxPuissance de Entreposage Réglages ET Révision Starter DU Commande LA Régler PourGAZ DES Commande Carburateur LE Régler PourChargée Mentretièen Batterie Déchargée OU Faible Batterie Carrossage AVANT/ Roues DES ConvergenceTionrecdi LA DE L’ALIGNEMENT Régler Pour 33 .Fig 32 .FigFIG LA Voir 31 .FigFIG LA Voir D’ENTRAÎNEMENT Courroie a L Acer Rempl Pour Tondeuse DE Lame DE Mentnetraî27 .Fig Tondeuse LA Niveau LE Ajuster Pour28 .Fig 26 .Fig21 .Fig 24 .Fig23 .Fig 20 .FigTondeuse LA Enlever Pour Reglages ET RevisionFig Voir 19 .Fig’ALLUMAGE Bougie Ligne EN Installé D’ESSENCE FiltreEntretien AIR À FiltreTransmission LA DE Entretien Fig la Voir Ventilation DE SystèmeLubrification Trapézoïdales CourroiesPneus Fig la Voir Lame LA EnleverLames DES Entretien Frein DU FonctionnementUtilisation Chaque Avant Ce de Réglages et Etretien section la dans réglages les TousFig la Voir Moteur LE Démarrer Pour UtilisationTonte DE Conseils 12 .FigMoteur DU D’HUILE Niveau LE Vérifier Accessoires Autres’ESSENCE Réservoir LE Remplir ET Charrettes DES Remorquer PourJauge DE Roues LES Régler Pour 10 .FigReculer Pour ET Avancer Pour GAZ DES Commande LA Utiliser PourFig la Voir Ment Netionsta DE Frein LE Engager PourDattachement Propriété la de lendommagement Correctement Sont Courroies LES MontageToutes SI Vérifier Toutes SI Vérifier Tionsec la Voir Rouler Faisant LE EN TE Assemblé PAS PiècesDesmancom des fonction la et Fig la Voir Siège LE Ajustez26-25 Dépannage DE Guide Sommaire23-18 Réglages ET Révision Enfants Sécurité DE RèglesTracteurs des sécurité toute En l’utilisation pour ConseilsPentes LES Dans Fonctionnement AvertissementTracteurs des sécurité toute en l’utilisation pour Conseils Général FonctionnementCom.pro-poulan.www web site notre Visitez AUX Imprimé