Poulan 96042011300, 432448 manual Table of Contents

Page 4

PRODUCT SPECIFICATIONS

Gasoline Capacity

1.50 Gallons

 

and Type:

Unleaded Regular

Oil Type (API-SG-SL):

SAE 30 (above 32°F)

 

SAE 5W-30 (below 32°F)

Oil Capacity:

W/Filter:

56 oz.

 

W/O Filter:

48 oz.

Spark Plug:

Champion RC12YC

 

(Gap: .030")

 

Ground Speed (MPH):

Forward:

 

 

1st

1.0

 

2nd

1.4

 

3rd

2.1

 

4th

3.1

 

5th

4.0

 

6th

5.1

 

Reverse:

1.6

Charging System:

3 Amps Battery

 

5 Amps Headlights

Battery:

AMP/HR:

28

 

Min. CCA:

230

 

Case Size:

U1R

Blade Torque:

45-55 FT. LBS.

 

 

 

CONGRATULATIONS on your purchase of a new tractor. It has been designed, engineered and manufactured to give you the best possible dependability and performance.

Should you experience any problem you cannot easily rem- edy, please contact your nearest authorized service center/ department. We have competent, well-trained technicians and the proper tools to service or repair this tractor.

Please read and retain this manual. The instructions will enable you to assemble and maintain your tractor properly. Always observe the “SAFETY RULES”.

CUSTOMER RESPONSIBILITIES

Read and observe the safety rules.

Follow a regular schedule in maintaining, caring for and using your tractor.

Follow the instructions under “Maintenance” and “Stor- age” sections of this owner’s manual.

WARNING: This tractor is equipped with an internal com- bustion engine and should not be used on or near any unimprovedforest-covered,brush-coveredorgrass-covered land unless the engine’s exhaust system is equipped with a spark arrester meeting applicable local or state laws (if any). If a spark arrester is used, it should be maintained in effective working order by the operator.

A spark arrester for the muffler is available through your nearest authorized service center/department.

In the state of California the above is required by law (Section 4442 of the California Public Resources Code). Other states may have similar laws. Federal laws apply on federal lands.

TABLE OF CONTENTS

SAFETY RULES

2-3

PRODUCT SPECIFICATIONS

4

CUSTOMER RESPONSIBILITIES

4

ASSEMBLY

5-6

OPERATION

7-12

MAINTENANCE SCHEDULE

13

MAINTENANCE

13-16

SERVICE AND ADJUSTMENTS

17-22

STORAGE

23

TROUBLESHOOTING

24-25

4

Image 4
Contents PB19546LT ModelSafety Rules Safe Operation Practices for Ride-On MowersGeneral Operation II. Slope OperationIII. Children ServiceIV. Towing Table of Contents Assembly Tools Required for AssemblyUnassembled Parts ToremovetractorfromcartonCheck Tire Pressure Check Deck LevelnessCheck for Proper Position of ALL Belts Check Brake SystemOperation Know Your Tractor HOW to USE Your Tractor To SET Parking Brake See FigStopping See Figs To USE Throttle Control D See FigTo Adjust Gauge Wheels See Fig To Adjust Mower Cutting Height See FigReverse Operation System ROS See Fig Before Starting the Engine Mowing Tips To Start Engine See FigMaintenance MaintenanceGeneral Recommendations ScheduleBattery TractorBlade Removal See Fig Check Operator Presence SystemTransaxle Maintenance EngineBelts LubricationCleaning To Install Mower See Fig Service and AdjustmentsTo Remove Mower See Fig Install belt on engine pulley M, in belt keepers G To Level Mower Turn nut right Turn nut left To raise mower To lower mowerTransaxle Gear Shift Lever NEUTRAL- Adjustment See Fig To Replace Mower Blade Drive Belt See FigTo Check Brake To Replace Motion Belt Drive See FigTo Start Engine with a Weak Battery See Fig Replacing Battery See FigFront Wheel TOE-IN/CAMBER To Remove Wheel for Repairs See FigTo Adjust Throttle Control Cable To Adjust Choke ControlTo Adjust Carburetor To Replace Headlight BulbStorage OtherFuel System Engine OILTroubleshooting Points Troubleshooting Only Ride UP and Down Hill Not Across Hill Degrees MAX Fold Alon THI Dotted Line REE LopeDegrés MAX Dépannage DE Guide Moteur le quand ieuxPuissance de Entreposage Starter DU Commande LA Régler Pour GAZ DES CommandeRéglages ET Révision Carburateur LE Régler PourCarrossage AVANT/ Roues DES Convergence Tionrecdi LA DE L’ALIGNEMENT Régler PourChargée Mentretièen Batterie Déchargée OU Faible Batterie 33 .Fig 32 .Fig31 .Fig FIG LA Voir D’ENTRAÎNEMENT Courroie a L Acer Rempl PourFIG LA Voir Tondeuse DE Lame DE MentnetraîTondeuse LA Niveau LE Ajuster Pour 28 .Fig27 .Fig 26 .Fig24 .Fig 23 .Fig21 .Fig 20 .FigReglages ET Revision Fig VoirTondeuse LA Enlever Pour 19 .FigLigne EN Installé D’ESSENCE Filtre Entretien’ALLUMAGE Bougie AIR À FiltreFig la Voir Ventilation DE Système LubrificationTransmission LA DE Entretien Trapézoïdales CourroiesFig la Voir Lame LA Enlever Lames DES EntretienPneus Frein DU FonctionnementUtilisation Chaque Avant Ce de Réglages et Etretien section la dans réglages les TousUtilisation Tonte DE ConseilsFig la Voir Moteur LE Démarrer Pour 12 .FigAccessoires Autres ’ESSENCE Réservoir LE RemplirMoteur DU D’HUILE Niveau LE Vérifier ET Charrettes DES Remorquer PourJauge DE Roues LES Régler Pour 10 .FigGAZ DES Commande LA Utiliser Pour Fig la Voir MentReculer Pour ET Avancer Pour Netionsta DE Frein LE Engager PourDattachement Propriété la de lendommagement Correctement Sont Courroies LES MontageToutes SI Vérifier Toutes SI Vérifier Assemblé PAS Pièces Desmancom des fonction la etTionsec la Voir Rouler Faisant LE EN TE Fig la Voir Siège LE Ajustez26-25 Dépannage DE Guide Sommaire23-18 Réglages ET Révision Sécurité DE Règles Tracteurs des sécurité touteEnfants En l’utilisation pour ConseilsAvertissement Tracteurs des sécurité toute en l’utilisation pour ConseilsPentes LES Dans Fonctionnement Général FonctionnementCom.pro-poulan.www web site notre Visitez AUX Imprimé