Poulan 96012006904 manual To Level Mower Housing, FRONT-TO-BACK Adjustment See Figs

Page 20

SERVICE AND ADJUSTMENTS

TO LEVEL MOWER HOUSING

Adjust the mower while tractor is parked on level ground or driveway. Make sure tires are properly inflated (See “PRODUCT SPECIFICATIONS” section of this manual). If tires are over or underinflated, you will not properly adjust your mower.

SIDE-TO-SIDE ADJUSTMENT (See Figs. 14 and 15)

•Raise mower to its highest position.

•At the midpoint of both sides of mower, measure height from bottom edge of mower to ground. Distance “A” on both sides of mower should be the same or within 1/4" of each other.

•If adjustment is necessary, make adjustment on one side of mower only.

•To raise one side of mower, tighten lift link adjustment nut on that side.

•To lower one side of mower, loosen lift link adjustment nut on that side.

NOTE: Each full turn of adjustment nut will change mower height about 1/8".

•Recheck measurements after adjusting.

BOTTOM EDGE

 

BOTTOM EDGE

OF MOWER TO

 

OF MOWER TO

GROUND

 

GROUND

A

GROUND LINE

A

FIG. 14

SUSPENSION ARM

LIFT LINK

ADJUSTMENT NUT

FIG. 15

FRONT-TO-BACK ADJUSTMENT (See Figs. 16 and 17)

IMPORTANT: DECK MUST BE LEVEL SIDE-TO-SIDE. IF THE FOLLOWING FRONT-TO-BACK ADJUSTMENT IS NECESSARY, BE SURE TO ADJUST BOTH FRONT LINKS EQUALLY SO MOWER WILL STAY LEVEL SIDE-TO-SIDE.

To obtain the best cutting results, the mower housing should be adjusted so that the front is approximately 1/8" to 1/2" lower than the rear when the mower is in its high- est position.

Check adjustment on right side of tractor. Measure distance “D” directly in front and behind the mandrel at bottom edge of mower housing as shown.

•Before making any necessary adjustments, check that both front links are equal in length.

•If links are not equal in length, adjust one link to same length as other link.

•To lower front of mower loosen nut “E” on both front links an equal number of turns.

•When distance “D” is 1/8" to 1/2" lower at front than rear, tighten nuts “F” against trunnion on both front links.

•To raise front of mower, loosen nut “F” from trunnion on both front links. Tighten nut “E” on both front links an equal number of turns. The two front links must remain equal in length.

•When distance “D” is 1/8" to 1/2" lower at front than rear, tighten nut “F” against trunnion on both front links.

•Recheck side-to-side adjustment.

MANDREL

“D”

“D”

FIG. 16

BOTH FRONT LINKS MUST BE EQUAL IN LENGTH

NUT “F”

NUT “E”

TRUNNION

FRONT LINKS

FIG. 17

20

Page 19 Page 21
Image 20
Page 19 Page 21
Contents PO17542LT ModelII. Slope Operation Safe Operation Practices for Ride-On MowersGeneral Operation IV. Towing ServiceIII. Children Table of Contents Contents of Hardware Pack Tools Required for Assembly To Remove Tractor from CartonBefore Removing Tractor from Skid Unpack CartonCheck Battery See Fig Check Tire Pressure Check Deck LevelnessCheck for Proper Position of ALL Belts Check Brake SystemOperation Know Your Tractor HOW to USE Your Tractor Reverse Operation System ROS To Operate Mower See FigTo Operate on Hills To TransportBefore Starting the Engine Check Engine OIL LevelADD Gasoline To Start Engine See FigMowing Tips Maintenance Schedule Lubrication ChartGeneral Recommendations Before Each USETractor Blade Removal See FigTo Sharpen Blade See Fig Important Special blade bolt is heat treatedBattery EngineBelts Transaxle CoolingCleaning Clean AIR ScreenAIR Filter MufflerTo Install Mower See Fig To Remove Mower See FigTo Level Mower Housing FRONT-TO-BACK Adjustment See FigsBelt Installation To Replace Mower Blade Drive Belt See FigTo Check Brake To Replace Motion Drive Belt See FigTransaxle Gear Shift Lever NEUTRAL- Adjustment See Fig To Adjust Steering Wheel ALIGN- MentTo Start Engine with a Weak Battery See Fig Front Wheel TOE-IN/CAMBERTo Adjust Throttle Control Cable To Adjust Choke ControlTo Adjust Carburetor To Replace Headlight BulbOther Fuel SystemEngine OIL CylindersTroubleshooting Points Problem Cause CorrectionEngine dies when Outdoor Products Customer Service Dept HOPCanada contact Stevens Creek Road Terry Fox Way Augusta, GA 30907 USAService Notes Suggested Guide for Sighting Slopes for Safe Operation Parts and Service Changere DE Pièces LES ET L’ENTRETIEN Degrés MAX Dentretien Notes Dept Service Customer Products Outdoor Canada Au AutoriséGarantie cette de exclus sont normal l’entretien et Initiale d’achat date la de compter à jours 90 dixDépannage DE Guide Défectueux estRalenti Entreposage MoteurRéglages ET Révision MoteurCarrossage AVANT/ Roues DES Convergence Tionrec -DI LA DE L’ALIGNEMENT Régler PourVitesses DE Boîte LA DE Mentgechan DE Levier DU Neutre AU RéglageCourroie LA Remplacer Pour Courroie Acer Rempl PourTransmission DE MENTNETRAÎD’EN Freins LES Vérifier PourDE Boîtier LE Niveau DE Mettre Pour SedeutonFig la Voir Tondeuse LA Installer Pour Reglages ET RevisionTracteur Tondeuse LA Enlever PourEntretien Transmission LA DE Refroidissement BatterieLubrification Trapézoïdales CourroiesEN Fonctionnement DE Système ET Fig la Voir Lame LA AffilerFig la Voir Lame LA Enlever Recommandations LES GénéralesLubrification DE Tableau Utilisation Chaque AvantUtilisé resoiceslac à et terrain au convient qui vitesse UtilisationTonte DE Conseils Moteur LE Démarrer DE Avant Moteur LE Démarrer Pour’ESSENCE Réservoir LE Remplir Moteur DU D’HUILE Niveau LE VérifierAccessoires Autres ET Charrettes DES Remorquer PourTracteur LE Transporter Pour Pentes LES Dans Utiliser PourGAZ DES Commande LA Utiliser Pour T O S I L I T UTeurtrac Reculer Pour ET Avancer Pour02829 Moteur Montage Correctement Sont Courroies LESToutes SI Vérifier Toutes SI Vérifier NI DE EST Tondeuse LA SI VérifierPalet LA DE Tracteur LE Retirer Pour Fig la Voir Batterie LA VérifierDesmancom des fonction la et DU Tracteur LE Sortir Pour LE Pour Exigés Outils LESPalette LA ToncarMontar SIN Piezas Produit DE Spécifications SommaireClient DU Responsabilités Entretien RemorquageEnfants Général EntretienPentes LES Dans FonctionnementGénéral Fonctionnement Tracteurs des sécurité toute en l’utilisation pour ConseilsAUX Imprimé

96012006904 specifications

The Poulan 96012006904 is a powerful and versatile lawn mower that offers a range of features designed to make lawn care easier and more efficient. This model stands out in the market due to its robust construction and innovative technologies aimed at enhancing mowing performance.

One of the key features of the Poulan 96012006904 is its powerful engine. Equipped with a reliable gas-powered engine, this mower delivers strong torque and efficient cutting performance. This ensures that users can easily tackle various types of grass and terrain without experiencing bogging or stalling.

The mower also boasts a self-propulsion system that allows users to maneuver the equipment effortlessly across their lawn. This feature is incredibly beneficial for maintaining speed and reduces the physical effort required during mowing, particularly on slopes or uneven ground. The adjustable speed settings provide users with the flexibility to match their pace, making the mowing process more comfortable.

Another standout characteristic of the Poulan 96012006904 is its cutting deck, which is designed to provide excellent grass cutting performance. With a generous cutting width, this mower can cover more ground in less time, making it suitable for larger lawns. Moreover, the cutting height adjustment feature provides users with the ability to customize the grass length to their preference, achieving a professional-looking cut.

The mower is also equipped with advanced technology such as a mulching capability, which allows users to finely chop grass clippings and return them to the lawn, promoting healthy growth and reducing the need for additional fertilizers. Furthermore, the rear discharge feature efficiently disperses grass clippings, minimizing windrowing and making clean-up easier.

The Poulan 96012006904 prioritizes user comfort and safety. The ergonomic handle grips provide superior comfort during operation, while the safety features ensure that the mower can only be engaged when properly operated, adding an essential layer of protection.

In conclusion, the Poulan 96012006904 is a standout choice for homeowners seeking a reliable and efficient lawn mower. With its powerful engine, self-propulsion system, adjustable cutting height, and mulching capabilities, it offers an excellent blend of performance and user-friendly features, making lawn maintenance a breeze. Whether tackling tough grass, tackling larger lawns, or simply wanting a well-kept yard, this mower has the capabilities to deliver impressive results.
Top Page Image Contents