TROUBLESHOOTING CHART
PROBLEM |
| CAUSE |
| CORRECTION |
Will not start | • | Out of fuel. | • | Fill fuel tank. |
| • | Engine not “CHOKED” | • | See “TO START ENGINE” |
|
| properly. |
| in Operation section. |
| • | Engine flooded. | • | Wait several minutes |
|
|
|
| before attempting to start. |
| • | Bad spark plug. | • | Replace spark plug. |
| • | Dirty air filter. | • | Clean/replace air filter. |
| • | Dirty fuel filter. | • | Replace fuel filter. |
| • | Water in fuel. | • | Drain fuel tank and |
|
|
|
| carburetor, refill tank with |
|
|
|
| fresh gasoline and replace |
|
|
|
| fuel filter. |
| • | Loose or damaged wiring. | • | Check all wiring. |
| • | Carburetor out of adjustment. | • | See “To Adjust Carburetor” |
|
|
|
| in Service Adjustments |
|
|
|
| section. |
| • | Engine valves out of | • | Contact an authorized |
|
| adjustment. |
| service center/department. |
|
|
|
|
|
Hard to start | • | Dirty air filter. | • | Clean/replace air filter. |
| • | Bad spark plug. | • | Replace spark plug. |
| • | Weak or dead battery. | • | Recharge or replace |
|
|
|
| battery. |
| • | Dirty fuel filter. | • | Replace fuel filter. |
| • | Stale or dirty fuel. | • | Drain fuel tank and refill |
|
|
|
| with fresh gasoline. |
| • | Loose or damaged wiring. | • | Check all wiring. |
| • | Carburetor out of adjustment. | • | See “To Adjust Carburetor” |
|
|
|
| in Service Adjustments |
|
|
|
| section. |
| • | Engine valves out of | • | Contact an authorized |
|
| adjustment. |
| service center/department. |
|
|
|
|
|
Engine will not | • | Clutch/brake pedal not | • | Depress clutch/brake |
turn over |
| depressed. |
| pedal. |
| • | Attachment clutch is | • | Disengage attachment |
|
| engaged. |
| clutch. |
| • | Weak or dead battery. | • | Recharge or replace |
|
|
|
| battery. |
| • | Blown fuse. | • | Replace fuse. |
| • | Corroded battery terminals. | • | Clean battery terminals. |
| • | Loose or damaged wiring. | • | Check/replace ignition |
|
|
|
| switch. |
| • | Faulty solenoid or starter. | • | Check/replace solenoid or |
|
|
|
| starter. |
| • | Faulty operator presence | • | Contact an authorized |
|
| switch(es). |
| service center/department. |
|
|
|
|
|
Engine clicks but | • | Weak or dead battery. | • | Recharge or replace battery. |
will not start | • | Corroded battery terminals. | • | Clean battery terminals. |
| • | Loose or damaged wiring. | • | Check all wiring. |
| • | Faulty solenoid or starter. | • | Check/replace solenoid or |
|
|
|
| starter. |
|
|
|
|
|
26