Poulan 179416 manual TRACTOR - - MODEL NUMBER PO14542D, Schematic

Page 27

TRACTOR - - MODEL NUMBER PO14542D

TRACTOR - - MODEL NUMBER PO14542D

SCHEMATIC

RED

BLACK

BATTERY

	A	RED
	A
AMMETER			FUSE
AMMETER
(OPTIONAL)
		WHITE
RED	B	S
	B	M	CLUTCH / BRAKE
	G		CLUTCH / BRAKE
	G	A1	(PEDAL UP)
	L	A2
BLACK	IGNITION
BLACK	SWITCH
	SWITCH
			BLACK
			BLACK
			HOUR
			METER
			(OPTIONAL)
			FUEL
		BLUE	LINE

		RED	M
			M
			STARTER
			BLACK
		SOLENOID
		WHITE
			SEAT SWITCH
			(NOT OCCUPIED)
	WHITE
		BLACK	BLACK
		ATT'MENT CLUTCH	GROUNDING
	BLACK	(CLUTCH OFF)	GROUNDING
	BLACK	(CLUTCH OFF)	CONNECTOR
			CONNECTOR

				SPARK
BLACK		IGNITION		PLUG
		UNIT		GAP
		UNIT	(2 PLUGS ON
			(2 PLUGS ON
			TWIN CYL. ENGINES)
	CHARGING SYSTEM OUTPUT		28 VOLTS AC MIN. @ 3600 RPM
	3 AMP DC @ 3600 RPM		(CHARGING SYSTEM DISCONNECTED)

	FUEL SHUT-OFF SOLENOID	RED
	FUEL SHUT-OFF SOLENOID
	(IF SO EQUIPPED)	LIGHTING SYSTEM OUTPUT
	(IF SO EQUIPPED)		DIODE

	ORANGE	5 AMP AC @ 3600 RPM
	ORANGE	5 AMP AC @ 3600 RPM

ALTERNATOR

14 VOLTS AC MIN. @ 3600 RPM (LIGHTS OFF)

IGNITION SWITCH

POSITION CIRCUIT “MAKE”

OFF	M+G+A1	NONE
RUN/LIGHT	B+A1	A2+L

NOTE

YOUR TRACTOR IS EQUIPPED WITH A SPECIAL ALTERNATOR SYSTEM. THE LIGHTS ARE NOT CONNECTED TO THE BATTERY, BUT HAVE THEIR OWN ELECTRICAL SOURCE. BECAUSE OF THIS, THE BRIGHTNESS OF THE LIGHTS WILL CHANGE WITH ENGINE SPEED. AT IDLE THE LIGHTS WILL DIM. AS THE ENGINE IS SPEEDED UP, THE LIGHTS

WILL BECOME THEIR BRIGHTEST.

WIRING INSULATED CLIPS

BROWN

BLACK

HEADLIGHTS

NON-REMOVABLE

CONNECTIONS

REMOVABLE

CONNECTIONS

RUN	B+A1	NONE
START	B + S + A1	NONE

NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE REPLACED TO PROPERLY SECURE YOUR WIRING.

27

Image 27

Contents 179416 4.20.01 TR PRINTED IN U.S.A MODEL NO. PO14542D 14.5 HP 42 Inch Lawn TractorII. SLOPE OPERATION SAFETY RULESIV. SERVICE I. GENERAL OPERATION25-26 TABLE OF CONTENTSSAFETY RULES Safe Operation Practices for Ride-On MowersCUSTOMER RESPONSIBILITIES PRODUCT SPECIFICATIONSKeys UNASSEMBLED PARTSSteering Wheel SeatBEFORE REMOVING TRACTOR FROM SKID ASSEMBLYTOOLS REQUIRED FOR ASSEMBLY TO REMOVE TRACTOR FROM CAR- TONHOW TO SET UP YOUR TRACTOR CHECK BATTERY See FigINSTALL SEAT See Fig CHECK FOR PROPER POSITION OF ALL BELTS CHECKLISTCHECK TIRE PRESSURE CHECK DECK LEVELNESSOPERATION KNOW YOUR TRACTOR STOPPING See Fig HOW TO USE YOUR TRACTORTO ADJUST MOWER CUTTING HEIGHT See Fig TO SET PARKING BRAKE See FigTO OPERATE ON HILLS BEFORE STARTING THE ENGINETO ADJUST GAUGE WHEELS See Fig TO OPERATE MOWER See FigMOWING TIPS ADD GASOLINETO START ENGINE See Fig BEFORE EACH USE CUSTOMER RESPONSIBILITIESGENERAL RECOMMENDATIONS LUBRICATION CHARTOPERATOR PRESENCE SYSTEM TRACTORBRAKE OPERATION TIRESTRANSAXLE COOLING ENGINEBATTERY V-BELTSCLEAN AIR SCREEN ENGINE COOLING FINS See FigAIR FILTER See Fig IN-LINE FUEL FILTER See Fig CLEANINGMUFFLER SPARK PLUGSTO REMOVE MOWER See Fig SERVICE AND ADJUSTMENTSTO INSTALL MOWER See Fig CAUTION BEFORE PERFORMING ANY SERVICE OR ADJUSTMENTSTO LEVEL MOWER HOUSING TO REPLACE MOWER BLADE DRIVE BELT See FigBOTH FRONT LINKS MUST BE EQUAL IN LENGTH TO REPLACE MOTION DRIVE BELT See Fig TO ADJUST BRAKE See FigTO ADJUST STEERING WHEEL ALIGNMENT TO START ENGINE WITH A WEAK BATTERY See FigINTERLOCKS AND RELAYS REPLACING BATTERY See Figs. 26 andTO REMOVE HOOD AND GRILL ASSEMBLY See Fig TO REPLACE HEADLIGHT BULBTO ADJUST CARBURETOR TO ADJUST THROTTLE CONTROL CABLE See FigENGINE OIL STORAGEOTHER FUEL SYSTEMCORRECTION TROUBLESHOOTING POINTSPROBLEM CAUSEEngine continues to run SCHEMATIC TRACTOR - - MODEL NUMBER PO14542DREPAIR PARTS ELECTRICAL2122 DESCRIPTION PARTCHASSIS AND ENCLOSURES PART 202 DRIVE154407 Bellcrank Clutch178394 STEERING ASSEMBLY 68678546 KEY PART NO. NO. DESCRIPTION ENGINE OPTIONAL EQUIPMENT Spark ArresterPART SEAT ASSEMBLY 179416 DECALSWHEELS & TIRES 179128MOWER LIFT PART MOWER DECK 179293 179292SERVICE NOTES LIMITED WARRANTY SERVICE WARRANTYPOLICY SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION