Homelite UT20004, UT20044, UT20045, UT20024, UT20025, UT20005 manual Manufacturers Warranty Coverage

Page 22

WARRANTY

THE FOLLOWING CARB STATEMENT ONLY APPLIES TO MODEL NUMBERS REQUIRED TO MEET (CARB) REQUIREMENTS.

HOMELITE CONSUMER PRODUCTS, INC. LIMITED WARRANTY FEDERAL AND CALI- FORNIA EMISSION CONTROL SYSTEMS NONROAD AND SMALL OFF-ROAD ENGINES

The U.S. Environmental Protection Agency (EPA), the California Air Resources Board (CARB), and Homelite Consumer Products, Inc. are pleased to explain the Emission Control System Warranty on your nonroad or small off-road engine. In California, new small off- road engines must be designed, built and equipped to meet the state's stringent anti-smog standards. In other states, new 2000 and later model year nonroad engines must be designed, built and equipped, at the time of sale, to meet the U.S. EPA regulations for small nonroad engines. The nonroad engine must be free from defects in materials and workmanship which cause it to fail to conform with U.S. EPA standards for the first two years of engine use from the date of sale to the ultimate purchaser. Homelite Consumer Products, Inc. must warrant the emission control system on your nonroad or small off-road engine for the period of time listed above provided there has been no abuse, neglect, or improper maintenance of your nonroad or small off-road engine.

Your emission control system may include parts such as the carburetor or fuel injection system, the ignition system, the catalytic con- verter. Also included may be hoses, belts, and connectors and other emission related assemblies.

Where a warrantable condition exists, Homelite Consumer Products, Inc. will repair your nonroad or small off-road engine at no cost to you, including diagnosis (if the diagnostic work is performed at an authorized dealer), parts, and labor.

MANUFACTURER'S WARRANTY COVERAGE:

The 1995 and later small off road engines are warranted for two years in California. In other states, 1997 and later model year nonroad engines are also warranted for two years. If any emission-related part on your engine is defective, the part will be repaired or replaced by Homelite Consumer Products, Inc. free of charge.

OWNER'S WARRANTY RESPONSIBILITIES

(a)As the nonroad or small off-road engine owner, you are responsible for the performance of required maintenance listed in your owner's manual. Homelite Consumer Products, Inc. recommends that you retain all receipts covering maintenance on your nonroad or small off-road engine, but Homelite Consumer Products, Inc., cannot deny warranty solely for the lack of receipts or for your failure to ensure the performance of all scheduled maintenance. Any replacement part or service that is equivalent in perfor- mance and durability may be used in non-warranty maintenance or repairs, and shall not reduce the warranty obligations of the engine manufacturer.

(b)As the nonroad or small off-road engine owner, you should be aware, however, that Homelite Consumer Products, Inc., may deny you warranty coverage if your nonroad or small off-road engine or a part has failed due to abuse, neglect, improper maintenance or unapproved modifications.

(c)You are responsible for presenting your nonroad or small off-road engine to a Homelite Consumer Products, Inc., service dealer as soon as a problem exists. The warranty repairs should be completed in a reasonable amount of time, not to exceed 90 days.

If you have any questions regarding your warranty rights and responsibilities, you should contact a Homelite Consumer Products, Inc., Customer Representative at 1-800-242-4672.

COVERAGE:

Homelite Consumer Products, Inc. warrants to the ultimate purchaser and each subsequent purchaser that your nonroad or small off- road engine will be designed, built and equipped, at the time of sale, to meet all applicable regulations. Homelite Consumer Products, Inc. also warrants to the initial purchaser and each subsequent purchaser that your nonroad or small off-road engine is free from de- fects in materials and workmanship which cause the engine to fail to conform with applicable regulations for a period of two years. The 1995 and later small off road engines are warranted for two years in California. In all other states for 1997 and later model years, EPA requires manufacturers to warrant non-road engines for two years. These warranty periods will begin on the date the nonroad or small off-road engine is purchased by the initial purchaser. If any emission-related part on your engine is defective, the part will be replaced by Homelite Consumer Products, Inc. at no cost to the owner.

Homelite Consumer Products, Inc. shall remedy warranty defects at any authorized Homelite Consumer Products, Inc. engine dealer or warranty station. Any authorized work done at an authorized dealer or warranty station shall be free of charge to the owner if such work determines that a warranted part is defective. Any manufacturer-approved or equivalent replacement part may be used for any warranty maintenance or repairs on emission-related parts, and must be provided free of charge to the owner if the part is still under warranty. Homelite Consumer Products, Inc. is liable for damages to other engine components caused by the failure of a warranted part still under warranty.

The California Air Resources Board's Emission Warranty Parts List specifically defines the emission-related warranted parts. (EPA's regulations do not include a parts list, but EPA considers emission-related warranted parts to include all the parts listed below.)

These warranted parts are: Carburetor, Spark Plug, Ignition, Air Filter and Fuel Filter.

MAINTENANCE REQUIREMENTS

The owner is responsible for the performance of the required maintenance as defined by Homelite Consumer Products, Inc. in the operator's manual.

LIMITATIONS

The Emission Control Systems Warranty shall not cover any of the following:

(a)repair of replacement required because of misuse or neglect, lack of required maintenance, repairs improperly performed or replacements not conforming to Homelite Consumer Products, Inc. specifications that adversely affect performance and/or dura- bility, and alterations or modifications not recommended or approved in writing by Homelite Consumer Products, Inc., and

(b)replacement of parts and other services and adjustments necessary for required maintenance at and after the first scheduled replacement point.

The Emissions Compliance Period referred to on the Emissions Compliance label indicates the number of operating hours for which the engine has been shown to meet Federal emission requirements. Category C=50 hours, B=125 hours, and A=300 hours.

Page 22

Page 21 Page 23
Image 22
Page 21 Page 23
Contents Operators Manual Table of Contents IntroductionGeneral Safety Rules Read ALL InstructionsSpecific Safety Rules Specific Safety Rules for Trimmer USESymbols Symbol Name ExplanationService Symbol Signal MeaningInstructions SpecificationsUnpacking Packing ListFeatures Trimlite model UT20004, UT20005Trim ‘n Edge model UT20024, UT20025 Front Handle AssemblySee Figure Straight Shaft Grass Deflector Easy Reach See Figures 5Fueling and Refueling the Trimmer OperationOperating the Trimmer Advancing the String Manually Trimlite and Trim ‘N EdgeAdvancing the String CUT OFF BladeEdger Guide Operation Trim ‘N Edge only See Figures 10To Start a Cold Engine Starting and StoppingSee To Stop the EngineNEW Prewound Spool MaintenanceSpool Replacement See Figures 14Cleaning the Exhaust Port and Muffler Spark Arrestor String ReplacementSee Figures 16 Spark Plug Replacing and Cleaning AIR FilterFuel CAP Storage 1 Month or LongerTroubleshooting Problem Possible Cause SolutionTroubleshooting Warranty Limited Warranty StatementManufacturers Warranty Coverage Emissions Maintenance Schedule and Warranted Parts List Homelite Consumer PRODUCTS, INC

UT20005, UT20004, UT20025, UT20024, UT20045 specifications

Homelite, a trusted name in outdoor power equipment, offers a versatile range of string trimmers and brushcutters designed to meet the diverse needs of homeowners and professionals alike. The models UT20005, UT20045, UT20025, UT20004, and UT20044 showcase the brand's commitment to innovation and efficiency.

The Homelite UT20005 is a powerful electric string trimmer that is lightweight and easy to handle. Its 10-amp motor delivers a strong performance, making it ideal for tackling overgrown grass and weeds. This model features an adjustable shaft for user comfort and can easily convert to an edger, providing dual functionality in one tool. The automatic feed spool allows for continuous operation without interruptions, ensuring a seamless trimming experience.

The UT20045 model takes performance a step further with its robust design and advanced features. Equipped with a 5-amp motor, this trimmer is suitable for both residential and light commercial use. It offers a variable speed trigger that allows users to control the power according to the task at hand. The dual-line system enhances cutting efficiency, making it easier to handle tougher vegetation.

For those seeking a more compact option, the UT20025 model is lightweight yet powerful. Its ergonomic design minimizes user fatigue, making it ideal for extended use. The trimming width is adjustable, allowing for precise cutting in hard-to-reach areas. This model is particularly favored by gardeners and hobbyists who appreciate its ease of use.

Moving on to the UT20004, this model emphasizes user convenience with a straight shaft design that provides better reach and reduces the need for bending. The 2-in-1 capability allows for quick conversion from trimmer to edger. This feature is particularly valuable for those with smaller yards looking for efficient solutions without the need for multiple tools.

Lastly, the UT20044 model stands out with its focus on durability and performance. Built with robust materials, it features a high-capacity battery that offers extended run times, enhancing productivity without the hassle of cords. The innovative brushless motor technology ensures quieter operation and requires less maintenance, making it an excellent choice for eco-conscious consumers.

In summary, Homelite’s UT20005, UT20045, UT20025, UT20004, and UT20044 models exemplify reliability and innovation in outdoor power equipment. With features tailored for various cutting tasks, these string trimmers and brushcutters combine performance, ease of use, and technological advancements to accommodate the needs of both casual users and professionals in lawn care.
Top Page Image Contents