Snapper 3314518BVE, 331518KVE, 281318BE, 301318BE Control Panel, Introduction, Nomenclature

Page 5

Section 1 - FAMILIARIZATION

FUEL

TANK

REAR

BUMPER

TRANSMISSION

SHIFT LEVER

DECK LIFT

LEVER

DISCHARGE

DEFLECTOR

MOWER DECK

CONTROL PANEL

IGNITION

SWITCH

ENGINE

SPEED

CONTROL

PARK

BRAKE

LEVER

FUELVENT FILLER

CAP

BLADE

LEVER

BLADE

PEDALS

FIGURE 1.1

STEERING

WHEEL

OPERATOR’S SEAT

CONTROL PANEL (See Insert)

CLUTCH/BRAKE

PEDAL

MOWER

BELT

COVER

1.1 INTRODUCTION

This manual has been prepared for the operator’s of the SNAPPER Rear Engine Rider. Its purpose, aside from recommending standard operating procedures and routine service requirements, is to promote SAFETY through the use of accepted operating practices. Read, Understand and Follow the IMPORTANT SAFETY INSTRUCTIONS on Pages 2 & 3 of this manual and All SAFETY messages on the Rear Engine Rider and its attachments before operating.

1.2 NOMENCLATURE

The nomenclature drawing above, Figure 1.1, shows the essential parts of the SNAPPER Rear Engine Rider. It is recommended that all operator’s of this equipment become thoroughly familiar with the controls, components, and operation of this machine before operating. Specific details involving the engine are found in the separate engine owner’s manual. Study these manuals before operating and keep both handy for future reference.

5

Image 5

Contents Manual No -7008 REV , 8/20/99 Rear Engine Riding Mower SeriesImportant Safety Instructions Operation Table of Contents Nomenclature Control PanelIntroduction PRE-START Check List OPERATOR’S Seat Adjustment 2.2.1. Front to Rear AdjustmentOn Next Starting & Operation Engine Electric StartEngine Manual Start Starting & OperationEngine Electric Start Wheel Drive Starting & Operation 2.3.3. Mower BladeMower Blade Stopping ENGINE, Wheel DRIVE, Blade 2.4.1. EngineDo not park machine on slopes Cutting Height AdjustmentStopping ENGINE, Wheel DRIVE, Blade 2.4.4. Park Brake Change Engine OIL Service After First 5 HoursService Engine AIR Cleaner Check Mower Blade Service Brake / Park Brake Service After First 5 Hours 3.2.4. Check Blade Drive BeltBlade Brake Interlock SystemBattery Fluid Level Service Every 25 Operating HoursClean Mower Deck Lubrication Grease FittingsLeft Rear Axle Bearing Grease Fitting Fuel Filter Service Annually 3.4.1. EngineEvery TWO Years Storage OUT of SeasonBlade Brake Adjustment Engine Adjustments & RepairFront to Rear Levelness 30 Decks Mower Deck & Component Adjustments Mower Deck AdjustmentFront to Rear Levelness 28, & 33 Decks Wheel Brake Adjustment Brake Cable Chain Case Loosen JAM Nuts Blade Sharpening Mower Blade Replacement 4.4.1. Blade Wear LimitsBelt Replacement Mower Drive Belt ReplacementBelt Removal Beltfigure 4.25 GuideBattery Installation Battery Battery RemovalBattery Storage Battery ServiceNEW Battery Preparation 1. Remove battery from carton Battery TestingSnapper Rear Engine Rider Accessories Stop Problem Probable Cause Corrective ActionBlades Not Cutting Loss Of TractionCutting Grass ImproperlyTo be Performed Pages Subject Service ReferenceMAINTENANCE/REPLACEMENT Parts Maintenance Parts Disclaimer of Warranty Year Limited WarrantyPrimary Maintenance Primary Maintenance Primary Maintenance Primary Maintenance Service Notes Rear Engine Riding Mower Series