TROUBLESHOOTING
CAUTION
Disconnect the machine from the power source before making any repair.
Symptom | Cause | Solution |
|
|
|
Motor will not start | On/Off switch is in the “OFF” | Turn switch to the “ON” (I) |
| (O) position. | position |
| Power cord is not plugged in. | Plug in power cord. |
| Electrical outlet does not | Try a different outlet. |
| supply adequate power. |
|
| Tripped circuit breaker. | Switch off pressure washer. |
|
| GFCI will reset once the tem- |
|
| perature of the unit drops. |
Unit does not reach | Diameter of garden hose is | Replace with a 5/8 inch gar- |
high pressure. | too small. | den hose. |
| Water supply is restricted. | Check garden hose for |
|
| kinks, leaks and blockage. |
| Not enough inlet water sup- | Open water source full force. |
| ply. |
|
| Water inlet filter is clogged. | Remove filter and rinse out |
|
| in warm water. |
| Spray wand is on low pres- | Turn spray wand to high |
| sure position. | pressure position. |
Output pressure | Not enough inlet water sup- | Turn water on full force. |
varies high and low. | ply. | Check garden hose for |
|
| kinks, leaks or blockage. |
| Pump is sucking air. | Check that hoses and fittings |
|
| are air tight. Turn off ma- |
|
| chine and purge pump by |
|
| squeezing trigger gun until a |
|
| steady flow of water emerg- |
|
| es through the nozzle. |
| Water inlet filter is clogged. | Remove filter and rinse out |
|
| in warm water. |
| Discharge nozzle is obstruct- | Blow out or remove debris |
| ed. | with a fine needle. |
| Calcified gun, hose or spray | Run distilled vinegar through |
| wand. | detergent suction tube. |
English 15