Bolens 12229 owner manual Troubleshooting, Problem Possible Cause Correction

Page 22

22Section 5: Maintenance

WARNING

Before inspecting, cleaning or servicing the machine, shut off engine, wait for all moving parts to come to a complete stop, disconnect spark plug wire and move wire away from spark plug.

Failure to follow these instructions can result in serious personal injury or property damage.

TROUBLESHOOTING

Before performing any troubleshooting procedures, refer to the appropriate safety, operating or maintenance instructions in this Manual or in the Engine Owner’s Manual. Contact your authorized engine service dealer for engine service. Contact your autho- rized tiller dealer or the factory for all other service problems.

 

PROBLEM

 

POSSIBLE CAUSE

 

CORRECTION

 

 

 

 

 

 

Engine does

1. Spark plug wire disconnected.

1.

Reconnect wire.

 

not start.

2. Engine Throttle Control Lever incorrectly set.

2.

Put lever in START position.

 

 

3.

Fuel tank empty.

3.

Add fuel.

 

 

4.

Choke control (if so equipped) in incorrect position.

4.

See Engine Owner’s Manual.

 

 

5.

Stale gasoline.

5.

Drain fuel and add fresh fuel.

 

 

6.

Dirty air filter(s).

6.

Clean or replace filter(s).

 

 

7.

Defective or incorrectly gapped spark plug.

7.

Inspect spark plug.

 

 

8.

Carburetor out of adjustment.

8.

See Engine Service Dealer.

 

 

9.

Misadjusted throttle control.

9.

See Engine Service Dealer

 

 

10.Dirt or water in fuel tank.

10. See Engine Service Dealer.

 

 

 

 

 

 

Engine runs poorly.

1. Defective or incorrectly gapped spark plug.

1.

Inspect spark plug (see Engine Owner’s Manual).

 

 

2.

Dirty air filter(s).

2.

Clean or replace (see Engine Owner’s Manual).

 

 

3.

Carburetor out of adjustment.

3.

See Engine Service Dealer.

 

 

4.

Stale gasoline.

4.

Replace with fresh gasoline.

 

 

5.

Dirt or water in fuel tank.

5.

See Engine Service Dealer.

 

 

6.

Engine cooling system clogged.

6.

Clean air cooling system (see Engine Owner’s Manual).

 

 

 

 

 

 

Engine overheats.

1. Engine cooling system clogged.

1.

Clean air cooling area (see Engine Owner’s Manual).

 

 

2.

Carburetor out of adjustment.

2.

See Engine Service Dealer.

 

 

3.

Oil level is low.

3.

Check oil level (see Engine Owner’s Manual).

 

 

 

 

 

 

Engine does not

1. Misadjusted throttle control or ignition switch.

1.

See Engine Owner’s Manual or Engine Service Dealer.

 

shut off.

 

 

 

 

 

 

 

 

 

 

Wheels and Tines

1. Improper use of controls.

1.

Review Sections 3 and 4.

 

will not turn.

2. Worn, broken, or misadjusted drive belt(s).

2.

See “Checking Drive Belt Tension,” Section 5.

 

 

3.

Internal transmission wear or damage.

3

Contact local dealer or the factory.

 

 

4.

Bolt loose in transmission pulley.

4.

Tighten bolt.

 

 

 

 

 

 

Tines turn, but

1. Wheel Drive Pins not in WHEEL DRIVE.

1.

See “Wheel Drive Pins” in Section 3.

 

wheels don’t.

2. Bolt loose in transmission pulley.

2.

Tighten bolt.

 

 

3.

Internal transmission wear or damage.

3.

Contact local Dealer or the Factory.

 

 

 

 

 

 

Wheels Turn, but

1. Tine holder mounting hardware missing.

1.

Replace hardware.

 

Tines Don’t.

2. Bolt loose in transmission pulley.

2.

Tighten bolt.

 

 

3.

Internal transmission wear or damage.

3.

Contact local Dealer or the Factory.

 

 

 

 

 

 

Poor tilling

1. Worn tines.

1.

See “Bolo Tines” (Section 5).

 

performance.

2. Improper Depth Regulator setting.

2.

See “Tilling Tips & Techniques,” Section 4.

 

 

3.

Incorrect throttle setting.

3.

See Section 4.

 

 

4.

Forward Drive Belt slipping.

4.

See “Checking Forward Drive Belt Tension,” Section 5.

 

 

 

 

 

 

 

 

 

 

 

 

Page 21 Page 23
Image 22
Page 21 Page 23
Contents Rear-Tine Tiller Table of Contents Know how to stop the unit and disengage the controls quickly Carefully read this Owner’sKeep children and pets away SafetyExercise caution to avoid slipping or falling Use slower engine speedsFor your safety and the safety To Avoid Serious InjuryIntroduction Assembly StepsInspect Unit Install Forward Clutch CableAssembly Check Level of Transmission Gear OILCheck all nuts and screws for tightness SafetyOperation Engine Controls Wheel Drive PinsIntroduction FreewheelForward Clutch Bail Features and ControlsHandlebar Height Adjustment Depth Regulator LeverStarting the Engine Pre-Start ChecklistBREAK-IN Operation Avoid engine muffler and nearbyTines will cause injury Stopping the Engine and Tiller Operating the TillerOperation Stopping the Tiller and EngineBy successive passes at one Quarter width see Fig Clumps of soil that can interfere withYour freshly tilled or cultivated soil Hood width, plus enough Extra room for future Plant growthTilling Up and Down Slopes Vertical Tilling Read the following recommendations before tilling on slopesTerrace Gardening Clearing the Tines Loading and Unloading the TillerTiller Lubrication Maintenance ScheduleTransmission Gear OIL Service Check for OIL LeaksRemoving/Installing a Tine Assembly MaintenanceRemoving/Installing a Single Tine Bolo TinesChecking and Adjusting Forward Drive Belt Tension Against the top of the adjuster BReplacement Belt Information Unhook the top of the spring from the Forward Clutch BailSpark Plug Service Forward Clutch Bail AdjustmentEngine Cleaning AIR Cleaner Service Engine OIL Service Spark Arrester Screen Service Throttle Lever AdjustmentCARBURETOR/GOVERNOR Control Adjustments OFF Season StorageTroubleshooting Problem Possible Cause CorrectionDrawing no Parts ListPart Description Parts List Parts List Drawing no Part Description QTY9512 9727 Forward Clutch Cable 1917326001 Left Side Right Side Hold Tine With Blunt End Toward YouDescription QTY 9711Engine Service and Repair Warranty ServiceReplacement Parts Owner Registration Card

12229 specifications

The Bolens 12229 is a powerful and versatile lawn tractor designed for homeowners seeking efficiency and reliability in their lawn care routine. This model is well-regarded for its robust construction and user-friendly features, making it suitable for a variety of lawn maintenance tasks.

At the heart of the Bolens 12229 is a dependable 29-horsepower gasoline engine. This provides ample power to handle diverse terrains and thick grass, ensuring a smooth and efficient mowing experience. The engine, combined with a 46-inch cutting deck, allows for coverage of larger areas in a shorter period. The cutting height can be easily adjusted, offering a range of options from 1.5 to 4 inches, accommodating various grass types and personal preferences.

One of the standout features of the Bolens 12229 is its hydrostatic transmission system. This technology offers seamless speed control without the need for gear shifting, allowing users to focus on the task at hand without distractions. The operator can simply press the pedal to accelerate or decelerate, which enhances maneuverability, especially in tight spaces and around obstacles.

The tractor is also equipped with comfortable seating and an ergonomic control layout, ensuring that users can operate it for extended periods without discomfort. Its tight turning radius enhances maneuverability, making it easier to navigate around flower beds and trees.

In terms of storage and utility, the Bolens 12229 comes with a built-in grass catcher option that helps to keep lawns tidy by easily collecting clippings. Additionally, it supports a variety of attachments, such as snow blades and carts, making it a multi-functional tool for year-round yard care.

Safety has not been overlooked; the model features a reliable safety switch that prevents engine start when the operator is not seated. This provides peace of mind, particularly for families with children around the yard.

Overall, the Bolens 12229 stands out in the market for its powerful performance, ease of use, and adaptability. Whether you're mowing a small backyard or tackling a larger landscape, this lawn tractor is designed to meet the demands of modern homeowners while providing excellent value for its price. Its combination of durability and innovative technology makes the Bolens 12229 an excellent choice for efficient lawn maintenance.
Top Page Image Contents