Husqvarna HUV 4214, HUV 4414-XP owner manual Periodic Service Schedule

Page 33

Periodic Service Schedule

WARNING

•Only trained technicians should service or repair the vehicle. Anyone doing even simple repairs or service should have knowledge and experience in electrical and mechanical repair. The appropriate instructions must be used when performing maintenance, service, or accessory installation.

•If any problems are found during scheduled inspection or service, do not operate vehicle until repairs are made. Failure to make necessary repairs could result in fire, property damage, severe personal injury, or death.

•Do not wear loose clothing or jewelry such as rings, watches, chains, etc., when servicing the vehicle.

•Turn key switch to the OFF position, remove the key, place the Forward/Reverse handle in the NEUTRAL position and chock the wheels prior to servicing.

•Moving parts: Do not attempt to service vehicle while engine is running.

•Hot! Do not attempt to service hot engine or exhaust system. Failure to heed this warning could result in severe burns.

•For vehicles with cargo beds, remove all cargo before raising the bed or servicing the vehicle. If the vehicle is equipped with a prop rod, ensure that it is securely engaged while bed is raised. Do not close bed until all persons are clear of cargo bed area. Keep hands clear of all crush areas. Do not drop cargo bed; lower gently and keep entire body clear. Failure to heed this warning could result in severe personal injury or death.

•Do not work on vehicle powertrain or under cargo bed when it is loaded.

•Turn fuel shut-off valve to the closed (OFF) position (Figure 11).

•To avoid unintentionally starting the vehicle:

–Disconnect battery cables, negative (–) cable first (Figure 2).

–Gasoline vehicles only: Disconnect the spark plug wires from the spark plugs.

•If wires are removed or replaced make sure wiring and wire harness are properly routed and secured. Failure to properly route and secure wiring could result in vehicle malfunction, property damage, personal injury, or death.

•Lift only one end of the vehicle at a time. Use a suitable lifting device (chain hoist or hydraulic floor jack) with 1000 lb. (454 kg) minimum lifting capacity. Do not use lifting device to hold vehicle in raised position. Use approved jack stands of proper weight capacity to support the vehicle and chock

the wheels that remain on the floor.

•When servicing the vehicle with part of the vehicle on jack stands, do not operate the engine with the Forward/Reverse handle in either the FORWARD or REVERSE position. The four-wheel drive system may engage any wheel(s), front or rear, depending on the mode selected. See Figure 3.

PERIODIC SERVICE SCHEDULE

See General Warnings on page 10.

WARNING

•Service, repairs, and adjustments must be made per instructions in the appropriate maintenance and service manual.

NOTE: If the vehicle is constantly subjected to heavy use or severe operating conditions, the preventive maintenance procedures should be performed more often than recommended in the Periodic Service and Lubrication Schedule.

Both the Periodic Service Schedule and the Periodic Lubrication Schedule must be followed to keep vehicle in optimum operating condition.

2009 HUV 4214, HUV 4414, andHUV 4414-XP Owner’s Manual

Page 31

Page 32 Page 34
Image 33
Page 32 Page 34
Contents Gasoline Utility Vehicles Page Page Foreword Table of Contents Page Safety Decal and Feature Identification Safety Decal and Feature IdentificationReplace Rops if damaged. Do not attempt repair ALL HUV 4214 and 4414 Vehicles949 Practice Safety Practice SafetyProposition 65 State of California Safety Details Safety DetailsGeneral Warnings General WarningsGeneral Warnings General Information Model IdentificationGeneral Information Controls and Indicators Controls and IndicatorsInstrument Panel KEY SwitchAccelerator Pedal FORWARD/REVERSE ControlBrake Pedal Park Brake HandlePark Brake Warning Light Front Axle ControlDifferential Lock Control LOW OIL Pressure Warning Light Fuel GAUGE/HOUR MeterHeadlight Control Roll-Over Protective Structure and Seat Belts ROLL-OVER Protective Structure and Seat BeltsSeat Latch and Adjustment Seat Latch and AdjustmentPre-Operation and Daily Safety Checklist PRE-OPERATION and Daily Safety ChecklistSee Vehicle Specifications on Performance InspectionDriving Instructions Driving InstructionsStarting the Vehicle Stopping the Vehicle Drive Train OperationParking and Leaving the Vehicle BED LatchBed Latch See General Warnings onBED Locking PIN Rear Shock AbsorbersBed Locking Pin Vehicle Load Capacities Loading and Unloading CargoTowing with the Vehicle Towing with the VehicleTransporting on a Trailer StorageTransporting on a Trailer Storage Preparing the Vehicle for Extended StorageReturning the Stored Vehicle to Service MaintenanceMaintenance Change engine oil. See Engine Oil and Filter Change onPeriodic Service Schedule Periodic Service SchedulePeriodic Service Schedule Regular Interval Periodic Lubrication Schedule Periodic Lubrication ScheduleBrake Fluid Reservoir Brake Fluid ReservoirBrake Fluid Engine OILEngine OIL Level Check Engine OilEngine Oil Draining Engine OIL and Filter ChangeEngine Oil Drain Plug and Oil Filter Wrench Remove Engine Oil Filter See following NoteEngine Oil Filling OIL ViscosityLubrication Change Front Differential and Rear Transaxle Gearcase LubricationGearcase Lubrication Front differentialRear Transaxle Drain Plug Rear transaxleAir Filter Installation AIR Filter ReplacementAIR Intake System Air Intake SystemFueling Instructions Fueling InstructionsBattery BatteryUsing a Booster Battery Jump Starting Using a Booster Battery Jump StartingCleaning the Vehicle Cleaning the VehicleElectric Winch Accessory AccessoriesAccessories MUD Tire OptionVehicle Specifications Subsequent Owner RegistrationSubsequent Owner Registration DIMENSIONS/WEIGHT Vehicle SpecificationsWarranties WarrantiesHOW to Make a Warranty Claim California Emission Control Warranty StatementHusqvarna Explanation of Emission Control Warranty Emissions Control Emissions ControlModerate IntermediateEmissions Control 103472540

HUV 4414-XP, HUV 4414, HUV 4214 specifications

The Husqvarna HUV 4414, HUV 4214, and HUV 4414-XP are all-terrain utility vehicles designed to excel in a variety of challenging conditions. These models are well-regarded for their robust construction, powerful performance, and advanced features, making them suitable for both professional and recreational applications.

Starting with the Husqvarna HUV 4414, this utility vehicle is powered by a reliable engine that delivers impressive torque, making it capable of handling heavy loads and navigating rough terrain with ease. The HUV 4414 boasts a generous cargo capacity, which includes a spacious bed designed to transport tools, equipment, or other materials. This model is equipped with a four-wheel drive system that enhances traction and stability on slippery or uneven surfaces.

Next, the HUV 4214 serves as a versatile option well-suited for light to medium-duty tasks. With its nimble design and responsive steering, it is perfect for tight spaces and maneuverability. The HUV 4214 features a user-friendly dashboard that provides seamless access to essential controls and information, ensuring operators can focus on the task at hand without unnecessary distractions. Its stable frame and suspension system allow for a smooth ride, regardless of the terrain.

Lastly, the HUV 4414-XP is the enhanced version of the HUV 4414, offering additional features tailored for heavier-duty applications. It comes with upgraded suspension for improved stability when carrying maximized loads. The powerful engine in the HUV 4414-XP not only delivers increased acceleration but also maintains efficiency during demanding usage. Enhanced storage options, an extendable cargo bed, and specialized towing capabilities further set this model apart, making it a go-to vehicle for both work and play.

Common characteristics across these models include durable, high-quality materials that ensure longevity and resilience. The vehicles are designed with user comfort in mind, featuring adjustable seats, ample legroom, and easy entry and exit. Safety is paramount, with reinforced frames and secure seatbelts providing added protection for operators and passengers.

In conclusion, the Husqvarna HUV 4414, HUV 4214, and HUV 4414-XP are impressive utility vehicles that cater to the diverse needs of users. Whether for work on a construction site, farming activities, or recreational fun, these models deliver performance, reliability, and versatility. With their strong build, advanced features, and innovative technologies, they stand out in the all-terrain utility vehicle market.
Top Page Image Contents