Subaru Robin Power Products RGX240D, RGX180 manual Safety Precautions, Phase

Page 28

6. SAFETY PRECAUTIONS

1.Use extreme caution near gasoline. A constant danger of explosion or fire exists.

Do not fill the fuel tank with gasolin u-hi12the engin is runmng. Do not smoke or use open tlame near the fuzl tank. Be car2ful not to spill fuel when refuueling.Ii spilt. wipe it and let dry before starting the engine.

2.Do not place inflammable materials near the generator.

Be careful not to put gasoline. matches. cwnpowd2r. oil cloth. straw. trash or an>-other inflammables near th2 gsnera- tor.

3.Do not operate the generator in a room. cave or tunnel. Always operate in a well-ventilated area.

Otherwiss the engme may become overheated and also, the poisonous carbon monoxide contained m th2 exhaust gases will endanger human lives. Keep the generator at least 1 m (4 fset) away from structums or facilities during use.

4.Operate the generator on a level surface.

If the generator is tilted or movzd during use. there is a dangsr of fuel spillage and a chance that the gensrator ma>-tip over.

5.Do not operate with wet hands or in the rain.

Severe electric shock may occur. If th2 generator is moistened by rain or snow. wipe it and fully drk- it before starting. Don’t pout Lvater over the generator directly- or wash it tvith water

If the generator is wet with Lvater. th2 insulations will be adverssly affected and may causecurrent leakage and electric shock.

6.Do not connect the generator to commercial pow-er lines.

This may cause a short-circuit or destroy the generator. Use a transf2r switch for connzcting with indoor lviring.

NOTE: The parrs numbers of the transfer switches and of the plastic box to store them are as shown in Table 6- 1.

 

Part No.

 

 

Part

Name

’ O’ty

; Phase

Allowable Current

 

 

 

 

 

 

 

I_

 

(

365 45604

08

 

Transfer

Switch

1

1

15A

 

3674560508

 

 

Transfer

Switch

1

1

30A

 

3404560608

 

 

Transfer

Switch

1

1

60A

 

340 45608

08

1

Transfer

Switch

1

3

15A

 

3484560908

 

;

Transfer

Switch

1

3

30A

 

3674300808

 

:

Plastic

Box

1

1.3

30A

 

3484300908

/

Plastic

Box

1

1

60A

Table 6- 1

7.Use fuses of the correct capacity.

If th2 generator rpm is increased exorbitantly in the overload condition by using a fus2 in excessof th2 rated capaiitl-. th2 gwerator could be burnt and the XYR 02 damaged.

CAUTION: If the fuse is burned out or the circuit breaker tripped off when using an electrical appliance, the cause may

be an overload or a short-circuit. in such a case, stop operation immediately and carefully check the electrical appliance and AC plugs for faulty wiring.

8.stopping

In stopping the gensrator. turn the speed control lever to the low position to slow it down to idling speed. and th2n stop it. If the generator is stopped suddenly from high speed. the sngiw may backfire.

- 26 -

Page 27 Page 29
Image 28
Page 27 Page 29
Contents Rain G Mot~ti’RG RGX240 Safety Circuit DiagramMembers For U. S. A. and Canadian markets Performance Model RGX240 EY20DModel RGX240D DC Output RGX240, RGX24OD Features Page Speed Control Leveh RGX180 Panel L 1 lOV RGX240 Panel L 1 lOV RGX240D Panel RUBB’ER Mount Functions RGX180 RGX240 AVR Automatic Voltage Regulator Circuit Breakers Fuse capxiry Receptacle and AC PlugsTerminals Front CoverRubber Mounts Rubber Vibration Isolators Rear CoverPipe Frame Shaft Page Primary Exciting Action Voltage Regulating MechanismDual Voltage Type RGX240D Change of Engine Parts 240 22OV Ignition SystemControl System Fuel System Cooling SystemAIR Guide Cylinder BaffleCarburetor Muffler Cover AIR CleanerOthers Safety Precautions PhaseRange of Applications Model RGX180 ~~~‘~ Measuring Procedure Used for measuring resistance, etc AC Output Measuring Rotor Checking Functional Members 11 OVi22OV Brushes AUR Automatic Voltage RegulatorRGX305D Fuse Holder Receptacle and AC Plug Diode Stack AssemblyVoltmeters and Pilot Lamp AVR Primary Exciting CircuitAs described m 5-3 Description of Generator OP Exciting CoilIO-2 HOW to Disassemble Remove6Q bolt Pss Remove the tit21 tank RemarksTool Box Spanner Be careful not to lose th2 RubbrrL4mm spannrr RemarksOrder Remarks Tool Frame Remove ths box sTa8g nut Pcs Remove Lift th2 generator with a r.hain blockOrder Procedure Brush holder Remove the brush cover ThemRemove the stator cover Turn up the stator cover edge 1Omm spanner or box spanner ScrewdriverSeparate the connector ar d wire If the stator does not come outInsert a screwdrive betaeen the front Cover and stator. and twist itProcedure Rotor Pull out Through-bolt. Fit a box Order Procedure Front cover Remove Front colderHead of the through-bolt. strike it Hard ounterclockwseHOW to Reassemble Spring washer pcs. Tightening torque 130 to 110 kg-mRear Cover Tighten the cover bolt ’ .zj Install the brush cover 49 x 10 mm screw pcs 6ox 15mmbolts PCSPCS Fig. lo-32 Fuel Tank Fig. lo-33 Push Does not work or pilot lamp does not light Cause TROUBLE-SHOOTINGRemedy +x+ CauseRemedyVoltage too low JUhuselRemedy IOK’ Off-load voltage is normal, but load cannot be Options CasterModel Contfol BOXModel RGX240D Generator Control BOX EngineSymbols Symbols NameSymbols Name Parts Model Rgxibo

RGX240, RGX240D, RGX180 specifications

Subaru Robin Power Products has established a strong reputation in the small engine market, offering reliable and efficient power solutions for various applications. Among their lineup, the RGX180, RGX240D, and RGX240 stand out, providing distinct features and technologies designed for performance and durability.

The RGX180 is a compact yet powerful generator. It is engineered for portability, making it ideal for home use, camping, or emergency situations. The RGX180 boasts a robust engine that delivers consistent performance with minimal fuel consumption. Its lightweight design allows for easy transportation without compromising on power output. Additionally, the RGX180 is equipped with a low oil shutdown feature, enhancing the engine's lifespan by preventing damage due to inadequate lubrication. This model is particularly known for its quiet operation, making it suitable for environments where noise is a concern.

On the other hand, the RGX240D is a dual-fuel generator, offering versatility by operating on both gasoline and propane. This feature ensures that users have fuel options available, especially during emergencies or in remote locations. The RGX240D provides higher wattage output, making it a reliable choice for larger appliances and tools. This model is especially appealing for contractors and outdoor enthusiasts who need dependable power for various machinery. Its rugged build and advanced technology contribute to its longevity and performance, even under strenuous conditions.

The RGX240 is a powerful generator designed for heavy-duty applications. With a high output capacity, it caters to users requiring reliable power for construction sites, events, or backup solutions for homes. The RGX240 incorporates advanced engine technologies, such as low emissions and fuel efficiency, aligning with modern environmental standards. It features a user-friendly control panel that provides easy access to monitoring power levels and alerts.

All three models reflect Subaru's commitment to quality and innovation. They feature ergonomic designs, ensuring ease of use during operation or transportation. Built with durable materials, these generators are capable of withstanding tough conditions, enhancing their reliability. Furthermore, Subaru offers excellent customer support and warranties that back these products, providing peace of mind to users.

In summary, the Subaru Robin Power Products RGX180, RGX240D, and RGX240 are engineered to meet diverse power needs while emphasizing reliability, efficiency, and user-friendliness. Their distinctive features and advanced technologies make them suitable choices for both casual users and professionals alike.
Top Page Image Contents