McCulloch 96192004102 owner manual Spacer, Retainer, Knob RED, Handle Knob, Washer 3/8

Page 27

REPAIR PARTS SNOW THROWER - - MODEL NUMBER MC627ES (96192004102)

HANDLES

						2
11				4	7
			8		7
			8
			9
		7 5	9
	6	7 5
	6					1
						1
3						13
	8					13
	8
			13			12
			13			14
						14
						14
				12		01.08.002-G
KEY	PART		DESCRIPTION
NO.	NO.		DESCRIPTION

1412683X431 CONTROL PANEL

2424517X431 CONTROL LEVER LH

3424516X431 CONTROL LEVER RH

4412679X008 TRACTION ROD ARM

5426918X008 IMPELLER ROD ARM

6412677 INTERLOCK BAIL

7	421613	SPACER
8	169675	RETAINER
9	17060410	SCREW 1/4-20 X .62
10	414280	KNOB BLACK
11	414281	KNOB RED
12	178899	HANDLE KNOB
13	19131316	WASHER 3/8
14	72120618	CARRIAGE BOLT 3/8-16 X 2.25

NOTE: All component dimensions given in U.S. inches. 1 inch = 25.4 mm

IMPORTANT: Use only Original Equipment Manufacturer (O.E.M.) replacement parts. Failure to do so could be hazardous, damage your snow thrower and void your warranty. 27

Image 27

Contents MC627ES Safe Operation Practices for Walk-Behind Snow Throwers Table of Contents Remove Snow Thrower from Carton Assembly / PRE-OPERATIONHOW to SET UP Your Snow Thrower Parts Packed Separately in CartonInstall Speed Control ROD See Figs Install Traction Drive Control ROD See FigsUnfold Upper Handle Install Auger Control ROD See Figs Install Discharge Chute / Chute Rotater Head See FigCheck Tire Pressure Ignition KEY OperationKnow Your Snow Thrower PrimerElectric start button used for starting the engine Meets A.N.S.I. Safety RequirementsTo USE Choke Control See Fig HOW to USE Your Snow ThrowerStopping To USE Fuel SHUT-OFF Valve See FigUsing the CLEAN-OUT Tool See Fig To Throw Snow See FigTo Move Forward and Backward See Fig Check Engine OIL Level See Fig To Adjust Skid Plates See FigBefore Starting the Engine Scraper BAR See FigIf Recoil Starter has Frozen Snow Throwing TipsTo Start Engine Before StoppingLubrication MaintenanceGeneral Recommendations Before Each USEEngine CleaningShear Bolts See Fig Service and AdjustmentsTo Adjust Snow Thrower Height Chute DeflectorTo Replace Belts See Fig Engine Speed To Adjust Cable Tension See FigTo Remove Wheels See Fig CarburetorEngine OIL StorageOther Fuel SystemTroubleshooting Exploded KEY Part Description Auger 27 RH Auger HousingScraper BAR Auger 27 LHSkid Plate RH Auger BearingBearing Plug Skid Plate LHStrap Chute WeldmentDeflector Weldment Deflector SealRotator Head LEVER/CABLE Rotator AssemblyCable Assembly Adjustable Cable Assembly Heat ShieldPivot Support Weldment 196944X431 Panel Bracket LH 196943X431 Panel Bracket RHHandle Grip Lower HandleHandle Knob SpacerRetainer Knob REDShifter ROD Bottom Impeller RODTraction ROD Shifter ROD TOPFlood Headlight Wire HarnessConsole Panel Headlight BezelRepair Parts Snow Thrower - Model Number MC627ES Drive Rubber Ring AssemblyDrive Plate Assembly Speed SelectorClik PIN Axle ShaftRoll PIN 3/16 SprocketEngine Mounting Plate Complete LCT EngineFrame 427963X428Idler Pulley Impeller BeltTraction Belt Idler ARM BracketWheel Assembly LH 432331X421432332X421 422663 Safety Ignition KEYDECAL, Danger 181037Service Notes Service Notes Limited Warranty

REPAIR PARTS SNOW THROWER - - MODEL NUMBER MC627ES (96192004102)

KEY

SPACER

RETAINER

KNOB BLACK

KNOB RED

HANDLE KNOB

WASHER 3/8