Multiquip manual MTX70 Safety Information, Safety Messages

Page 6

Do not operate or service the equipment before reading the entire manual. Safety precautions should be followed at all times when operating this equipment.

Failure to read and understand the safety messages and operating instructions could

result in injury to yourself and others.

SAFETY MESSAGES

The four safety messages shown below will inform you about potential hazards that could injure you or others.The safety messages speciﬁcally address the level of exposure to the operator and are preceded by one of four words: DANGER, WARNING, CAUTION or NOTICE.

SAFETY SYMBOLS

DANGER

Indicates a hazardous situation which, if not avoided, WILL result in DEATH or SERIOUS INJURY.

WARNING

Indicates a hazardous situation which, if not avoided, COULD result in DEATH or SERIOUS INJURY.

CAUTION

Indicates a hazardous situation which, if not avoided, COULD result in MINOR or MODERATE INJURY.

NOTICE

Addresses practices not related to personal injury.

MTX70 — SAFETY INFORMATION

Potential hazards associated with the operation of this equipment will be referenced with hazard symbols which may appear throughout this manual in conjunction with safety messages.

PAGE 6 — MTX70 — OPERATION AND PARTS MANUAL — REV. #12 (02/22/12)

Image 6

Contents Model MTX70 MTX70 Proposition 65WARNING MTX70 Operation and Parts Manual REV. #12 02/22/12 MTX70 -TABLE of Contents Parts Ordering Procedures Ordering parts has never been easierMTX70 Safety Information Safety MessagesMTX70 Safety Information Engine Safety Transporting Safety MTX70 General Information Definition of Tamping RammerMTX70 Specifications MTX70 Controls and Components MTX70 Basic Engine Initial ServicingMTX70 Operation EngineThrottle Lever Idle Position Normal Shutdown MTX70 Maintenance DailyMTX70 -TROUBLESHOOTING Guide MTX70 -TROUBLESHOOTING Guide MTX70-EXPLANATION of Parts Section Remarks Xxxxx only Not Used onMTX70- Suggested Spare Parts MTX70- Nameplate and Decals Name Plate and Decals Decal Operation Decal AIR CleanerMTX70- Nameplate and Decals Includes Items W/ #MTX70 Crankcase and Engine Assy Crankcase and Engine AssyBase CP, AIR Cleaner Connecting RODAIR Cleaner Cover CP Stud Bolt 10 XMTX70 Crankcase and Engine Assy KNOB, Cleaner Cover COVER, Cleaner UpperCOVER, Cleaner Lower Throttle WireMTX70 Guide Cylinder and Spring Assy Guide Cylinder and Foot AssyPiston ROD Piston PINPLUG, Piston PIN0 Piston ENDMTX70 Foot Assy Foot AssyNylon NUT M12 Grip HandlebarMTX70 -TANK and Handle Assy Tank and Handle AssyPart Name QTY Remarks MTX70 Combination Lever Assy Combination Lever AssyIncludes Items W/@ Wire CAPSocket Head SCREW/TH.WIRE See Note on DrawingMTX70 -TOOLS ToolsPiston ROD Holder Clutch Puller aClutch Mounter Crank Gear RemoverHonda GX100UKRBF Engine Cylinder Barrel Assy Honda GX100UKRBF Engine Cylinder Barrel Assy NO. Part no Part Name QTYHonda GX100UKRBF Engine Crankcase Cover Assy Honda GX100UKRBF Engine Crankcase Cover Assy Flange Joint PTOHonda GX100UKRBF Engine Crankshaft Assy Honda GX100UKRBF Engine Crankshaft Assy Honda GX100UKRBF Engine Piston Connecting ROD Assy Piston Connecting ROD Assy Honda GX100UKRBF Engine Camshaft Assy Honda GX100UKRBF Engine -CAMSHAFT Assy Honda GX100UKRBF Engine Recoil Starter Assy Honda GX100UKRBF Engine Recoil Starter Assy Honda GX100UKRBF Engine FAN Cover Assy Honda GX100UKRBF Engine FAN Cover Assy Honda GX100UKRBF Engine Carburetor ASSY. S/NT-3362 and below Honda GX100UKRBF Engine Carburetor ASSY. S/NT-3362 and below Honda GX100UKRBF Engine Carburetor ASSY.S/NT-3363 and Above Honda GX100UKRBF Engine Carburetor ASSY.S/NT-3363 and Above Honda GX100UKRBF Engine AIR Cleaner Assy Honda GX100UKRBF Engine AIR Cleaner Assy Honda GX100UKRBF Engine Muffler Assy Honda GX100UKRBF Engine Muffler Assy Honda GX100UKRBF Engine Flywheel Ignition Assy Honda GX100UKRBF Engine Flywheel Ignition Assy Starter PulleyHonda GX100UKRBF Engine Control Assy Honda GX100UKRBF Engine Control Assy Honda GX100UKRBF Engine Labels Assy Honda GX100UKRBF Engine Labels Assy Terms and Conditions of Sale Parts MTX70 Operation and Parts Manual REV. #12 02/22/12 HERE’S HOW to GET Help