Stow STR36SP WASHER, LOCK, 3/8 MED, BAR, 1 Control Pivot, Rocker BLOCK, 1.0 Hole, Pivot Tube

Page 47

STR36SP-SERIES — PIVOT ASSY. (RIGHT/LEFT)

PIVOT ASSY. (RIGHT/LEFT)

 

 

NO.

PART NO.

PART NAME

QTY.

REMARKS

1

1023

SCREW, HHC 3/8- 16 X 1-1/4

10

 

2

0166A

WASHER, LOCK, 3/8 MED.

18

 

3

2824

BAR, 1” CONTROL PIVOT

2

 

4

20040

ROCKER BLOCK, 1.0 HOLE

4

 

5

10138

SCREW, SHS 5/16- 18 X 5/16

4

 

6

2044

ARM, PIVOT RIGHT HAND

1

 

7

2079

ROCKER BLOCK WITH BUSHING

4

 

8

4196

SCREW, HHC 3/8- 16 X 3/4

8

 

9

20011

PLATE, GEARBOX ADAPTOR, RIGHT

1

 

10

1394

SCREW, FHSC 3/8- 16 X 1

8

 

11

11772

SHIM TRUNNION .062 THK

1

USE AS NEEDED

12

11773

SHIM, TRUNNION .031 THK

1

USE AS NEEDED

13

2076

PIVOT TUBE

1

 

14

10133

NUT, NYLOC 3/8- 16

4

 

15

10973

ROCKER BLOCK

2

 

16

20004

PLATE, GEARBOX ADAPTOR, LEFT

1

 

17

1481

SCREW, FHSC 3/8- 16 X 1- 3/4

4

 

STR36SP- SERIES • RIDE-ON POWER TROWEL — OPERATION AND PARTS MANUAL — REV. #1 (09/16/11) — PAGE 47

Page 46 Page 48
Image 47
Page 46 Page 48
Contents STR36SP Proposition 65WARNING Silicosis Warning SILCOSIS/RESPIRATORYWARNINGSTable of Contents Order via Fax Dealers Only Parts Ordering ProceduresBest Deal! Order via Internet Dealers Only Machine layout, location of components, checking of engine Training ChecklistDaily PRE-OPERATION Checklist Daily PRE-OPERATION ChecklistYou can be Injured if you do not follow these directions STR36SP-SERIES Safety Message Alert SymbolsAlways wear approved eye and hearing protection STR36SP-SERIES Safety Message Alert SymbolsAlways wear approved respiratory protection Fatigue, illness or taking medicine Do not operate or service this equipmentLifting the Ride-On Trowel STR36SP-SERIES Rules for Safe OperationAlways keep the work area well organized Transporting Towing Safety PrecautionsBattery STR36SP-SERIES Rules for Safe OperationAlways know the location of the nearest first aid kit Maintenance SafetyEmergencies Machine Safety Decals STR36SP-SERIES Operation and Safety DecalsTBD STR36SP-SERIES- Specifications TrowelSTR36 Engine Specifications STR36SP-SERIES- Specifications EngineSTR36SP-SERIES General Information STR36SP-SERIES Controls and Indicators Safety Stop Switch Shuts down engine when seat is empty STR36SP-SERIES Controls and IndicatorsFlow of fuel STR36SP-SERIES Basic EngineElement MixtureSeat Assembly STR36SP-SERIES NEW Machine Setup InstructionsTrowel Pre-Set Up Instructions Control Handle AssemblyGearbox Oil Level Engine Oil Level Always check engine oil Before Each USESTR36SP-SERIES Operation Steering STR36SP-SERIES OperationSTR36SP-SERIES Maintenance STR36SP-SERIES Maintenance  Have a 3/4 X 1 X 3-1/4 inch wooden block available Checking The Drive BeltRemoving the Drive Belt CV-Joint STR36SP-SERIES- MaintenanceReinstall the spare belt carrier and the drive belt guard Wooden BlockSpare Drive Belt Replacement STR36SP-SERIES- MaintenanceTorque Converter/Variable Pitch Pulley Drive Pulley Drive System Theory of OperationMatching Blade Pitch for Both Sets of Blades How It Works Figure Condition a  Engine IdlingClutch Blade PitchStabilizer Ring Removal Trowel Arm adjustment ProcedureSpider Plate Hex Head Bolt Zerk Fitting Trowel Arm RemovalRemove the trowel arm from the spider plate Trowel Blade RemovalChecking Trowel Arm Straightness Trowel Arm AdjustmentRe-Assembly Trowel Arm Adjustment SetupDecommissioning Trowel/Components Installing Pans Onto Finisher BladesSTR36SP-SERIES -TROUBLESHOOTING Engine STR36SP-SERIES -TROUBLESHOOTING Engine Troubleshooting STR36SP-SERIES-TROUBLESHOOTING TrowelTroubleshooting STR36SP-SERIES-TROUBLESHOOTING TrowelSTR36SP-SERIES Notes Xxxxx only Not Used on STR36SP-SERIES Explanation of Codes in Remarks ColumnSTR36SP-SERIES Suggested Spare Parts Decals STR36SP-SERIES DecalsDECAL, Protective Clothing DECAL, Spring SafetyDECAL, Powder Coated TBD DECAL, Stow DECAL, AL. Pitch RH TBD DECAL, AL. Pitch LHPivot ASSY. RIGHT/LEFT STR36SP-SERIES Pivot ASSY. RIGHT/LEFTARM, Pivot Right Hand WASHER, LOCK, 3/8 MEDBAR, 1 Control Pivot Rocker BLOCK, 1.0 HoleSteering Handles ASSY, Left and Right STR36SP-SERIES Steering Handles ASSY. Left and RightHANDLE, STEERING, Lower GRIP, HandleROD END, 3/8-24 Male RH HANDLE, TubeSteering Control ASSY., Left and Right STR36SP-SERIES Steering Control ASSY. Left and RightWASHER, Lock 3/8 MED Assist ASSEMBLY, SteeringROD END, 1/2-20 Male RH WASHER, Flat 1/2 SAEGearbox ASSY. Right Side STR36SP-SERIES Gearbox ASSY. Right Side20353 200655031A SCREW, RHM 1/4- 20 X 1/2 0948 12981Gearbox ASSY. Left Side STR36SP-SERIES Gearbox ASSY. Left Side12%+ 0232A 1298210989 STUD, N10- 32 X 3/4 12907 10% 12583 SPACER, X 11D X 1.168L 11%+ 9045Single Pitch Handle ASSY. Left and Right STR36SP-SERIES Single Pitch Handle ASSY. Left and RightCrank Lever Cable AssemblyCrank Knob SpacerDrive Assy STR36SP-SERIES Drive AssyKEY, Woodruff #9 GASKET, CV Joint BootBOOT, CV Joint PLATE, Bearing MountMUFFLER/BELT Assy STR36SP-SERIES MUFFLER/BELT AssyWASHER, Flat 5/16 USS ENGINE, Honda 24 HP GX670MUFFLER, 24 Honda WASHER, Lock 5/16 MediumBelt Guard Assy STR36SP-SERIES Belt Guard AssyBelt Guard Spider ASSY. Right STR36SP-SERIES Spider ASSY. RightWear Ring SCREW, Trowel AdjustmentBlade Assembly PLATE, Wear Thrust CollarSpider ASSY. Left STR36SP-SERIES Spider ASSY. LeftARM, Trowel Left SPRING, LH Trowel ARM LeverLEVER, Trowel ARM Left Hand Yoke Assy STR36SP-SERIES -YOKE AssyPIN, Yoke YokeFoot PEDALS/THROTTLE Assy STR36SP-SERIES Foot PEDALS/THROTTLE AssyRISER, Left Foot CABLE, Control 10-32 X 33 LongSPRING, Throttle Return WASHER, Flat #10 SAEControl Panel Assy STR36SP-SERIES Control Panel AssyHARNESS, Wire Honda Rider SWITCH,TOGGLE Electric #9061Wire ASSEMBLY, 16 GA. X BOOT, Toggle SwitchFRAME/FUEL Assy STR36SP-SERIES FRAME/FUEL AssyBUSHING, Rubber Fuel Fuel Pump AssemblyTANK, Fuel Five Gallon Fuel CAP/GAUGEBattery Assy STR36SP-SERIES Battery AssyBOOT, Terminal Bracket Battery HOLD- DownBOLT, Battery Hold Down BOX, Battery GR UISeat Frame Assy STR36SP-SERIES Seat Frame AssySeat Plate CONNECTOR, RelaySWITCH, Kill COLE- HER #90036 TERMINAL, Wire PioneerAIR Cleaner Assy Honda GX-670 AIR Cleaner AssyPLATE, AIR Cleaner Setting CLIP, AIR CleanerSEAL, AIR Cleaner Housing SEAL, AIR Cleaner CoverCamshaft Assy Honda GX-670 Camshaft AssyARM, Valve Rocker SPRING, Weight ReturnSEAL, Valve Stem ROD, PushCarburetor Assy Honda GX-670 Carburetor AssyGasket SET GASKET, AIR CleanerTUBE, Breather CLIP, Breather TubeControl 2 Assy Honda GX-670 Control AssyARM, Governor Lever ASSEMBLY,THROTTLEJOINT, ROD SPRING, StarterControl BOX Assy Honda GX-670 Control BOX AssyCASE, Control BRACKET, Case Mounting BRACKET, Wire Harness Clip SUB- Wire Harness AssemblyKEY Comp HOLDER, Stop Switch Wire SCREW, Special 6 X CLIP, Wire HarnessCrankcase Cover Assy Honda GX-670 Crankcase Cover AssyPIN, Governor Weight Cover ASSEMBLY, OIL PumpWEIGHT, Governor HOLDER, Governor WeightCrankshaft Assy Honda GX-670 Crankshaft Assy90401ZJ1000 Crankshaft COMP., T-TYPECylinder Barrelassy Honda GX-670 Cylinder Barrel AssyGASKET, Breather Cover CLAMP, WireSWITCH, OIL Pressure COVER, BreatherCylinder Head Assy Honda GX-670 Cylinder Head AssyGASKET, Cylinder Head HANGER, EngineGUIDE, Valve OS, Optional CLIP, Valve GuideFAN Cover Assy Honda GX-670 FAN Cover AssySHROUD, Right COVER, FAN *NH1* BlackPLATE, Right Side PLATE, Left SideFLY Wheel Assy Honda GX-670 Flywheel AssyFLY Wheel Comp PLATE, Cooling FAN SettingFAN, Cooling GRID, Screen P.T.O. OptionalFuel Pump Assy Honda GX-670 Fuel Pump AssyTube B, Fuel Pump ASSEMBLY, FuelSTAY, Fuel Pump TUBE, FuelIgnition Coil Assy Honda GX-670 Ignition Coil AssyCoil ASSEMBLY, Charge 12V/20A Coil Assembly R. IgnitionGROMMET, Ignition Wire Coil ASSEMBLY, L.. IgnitionLabels Assy Honda GX-670 Labels AssyMARK, Emblem Honda GX-670 Labels AssyOIL Cooler Assy Honda GX-670 OIL Cooler AssyHose A, OIL Collar 12MMCooler COMP., OIL GRILLE, OIL CoolerPiston + Connecting ROD Assy Honda GX-670 Piston + Connecting ROD AssyRing SET, Piston 0.75 Optional ROD Assembly ConnectingBOLT, Connecting ROD 6 X Ring SET, Piston STDStarter Motor Assy Honda GX-670 Starter Motor AssyLEVER, Pinion Drive Switch ASSEMBLY, MagnetRING, Snap Denso Collar SET, Clutch StopPayment Terms Terms and Conditions of Sale PartsSTR36SP-SERIES-NOTES HERE’S HOW to GET Help
Top Page Image Contents