Stow manual STR36SP-SERIES- Maintenance, Wooden Block, CV-Joint, New Spare Drive Belt

Page 28

STR36SP-SERIES— MAINTENANCE

3.Insert the 3/4" X 1" X 3-1/4" block between the moveable face and the fixed face of the lower drive pulley. See Figure 18. This block will help keep the lower drive pulley faces open while installing the new drive belt.

1

Wooden Block

Figure 18. Holding Lower Pulley Open

4.If the belt is not being reused (recommended), CUT the drive belt. Ensure all belt remnants are removed from the pulleys.

Installing the Drive Belt (Using Replacement Drive Belt)

The STR36SP-SERIES Ride-On PowerTrowel is equipped with a replacement drive belt (spare) carrier, which is mounted on the inboard side of the fuel tank near the clutch. Make sure that there is ALWAYS a spare drive belt in the drive belt carrier before the trowel is placed on a slab to finish concrete.

In the event of a drive belt failure, the spare (replacement) drive belt can be used for quick replacement at the job site to continue trowel operation.

1.If necessary, refer to Removing Drive Belt Instructions. Ensure all remnants of old belt have been removed from pulleys.

2.To replace the drive belt with the spare drive belt, remove the 2 bolts that secure the drive belt carrier. (Figure 19) This will allow free movement of the belt for installation. Take care with to not contaminate the relplacement belt with grease or dirt.

3.With the 3/4 x 1 x 3-1/4 wood block holding the lower pulley open, place the replacement belt into the lower pulley first. Work the belt over the upper drive pulley into the pulley groove.

4.Squeeze the belt enough to remove the wood block. With the block removed, release the tension on the belt.

5.Reinstall the spare belt carrier and the drive belt guard.

6.Replace the spare belt before the next trowel use. See spare drive belt replacement procedures.

2 1

			3
	4		1	Bolt, Spare Drive Belt Carrier
	4	5	2	Spare Drive Belt Holder
		5	2	Spare Drive Belt Holder
		6	3	Wooden Block
			4	CV-Joint
	Figure 19. Drive Belt Install		5	New Spare Drive Belt
	Figure 19. Drive Belt Install		6	Lower Drive Pulley
			6	Lower Drive Pulley

STR36SP-SERIES • RIDE-ON POWER TROWEL — OPERATION AND PARTS MANUAL — REV. #1 (09/16/11) — PAGE 28

Image 28

Contents STR36SP Proposition 65WARNING SILCOSIS/RESPIRATORYWARNINGS Silicosis WarningTable of Contents Best Deal! Order via Internet Dealers Only Parts Ordering ProceduresOrder via Fax Dealers Only Training Checklist Machine layout, location of components, checking of engineDaily PRE-OPERATION Checklist Daily PRE-OPERATION ChecklistSTR36SP-SERIES Safety Message Alert Symbols You can be Injured if you do not follow these directionsAlways wear approved respiratory protection STR36SP-SERIES Safety Message Alert SymbolsAlways wear approved eye and hearing protection Do not operate or service this equipment Fatigue, illness or taking medicineAlways keep the work area well organized STR36SP-SERIES Rules for Safe OperationLifting the Ride-On Trowel Towing Safety Precautions BatterySTR36SP-SERIES Rules for Safe Operation TransportingEmergencies Maintenance SafetyAlways know the location of the nearest first aid kit STR36SP-SERIES Operation and Safety Decals Machine Safety DecalsSTR36SP-SERIES- Specifications Trowel TBDSTR36SP-SERIES- Specifications Engine STR36 Engine SpecificationsSTR36SP-SERIES General Information STR36SP-SERIES Controls and Indicators STR36SP-SERIES Controls and Indicators Safety Stop Switch Shuts down engine when seat is emptySTR36SP-SERIES Basic Engine ElementMixture Flow of fuelSTR36SP-SERIES NEW Machine Setup Instructions Trowel Pre-Set Up InstructionsControl Handle Assembly Seat AssemblyEngine Oil Level Always check engine oil Before Each USE Gearbox Oil LevelSTR36SP-SERIES Operation STR36SP-SERIES Operation SteeringSTR36SP-SERIES Maintenance STR36SP-SERIES Maintenance Removing the Drive Belt Checking The Drive Belt Have a 3/4 X 1 X 3-1/4 inch wooden block available STR36SP-SERIES- Maintenance Reinstall the spare belt carrier and the drive belt guardWooden Block CV-JointSTR36SP-SERIES- Maintenance Spare Drive Belt ReplacementDrive System Theory of Operation Torque Converter/Variable Pitch Pulley Drive PulleyHow It Works Figure Condition a  Engine Idling ClutchBlade Pitch Matching Blade Pitch for Both Sets of BladesTrowel Arm adjustment Procedure Stabilizer Ring RemovalTrowel Arm Removal Remove the trowel arm from the spider plateTrowel Blade Removal Spider Plate Hex Head Bolt Zerk FittingTrowel Arm Adjustment Checking Trowel Arm StraightnessTrowel Arm Adjustment Setup Re-AssemblyInstalling Pans Onto Finisher Blades Decommissioning Trowel/ComponentsSTR36SP-SERIES -TROUBLESHOOTING Engine STR36SP-SERIES -TROUBLESHOOTING Engine STR36SP-SERIES-TROUBLESHOOTING Trowel TroubleshootingSTR36SP-SERIES-TROUBLESHOOTING Trowel TroubleshootingSTR36SP-SERIES Notes STR36SP-SERIES Explanation of Codes in Remarks Column Xxxxx only Not Used onSTR36SP-SERIES Suggested Spare Parts STR36SP-SERIES Decals DecalsDECAL, Spring Safety DECAL, Powder Coated TBD DECAL, StowDECAL, AL. Pitch RH TBD DECAL, AL. Pitch LH DECAL, Protective ClothingSTR36SP-SERIES Pivot ASSY. RIGHT/LEFT Pivot ASSY. RIGHT/LEFTWASHER, LOCK, 3/8 MED BAR, 1 Control PivotRocker BLOCK, 1.0 Hole ARM, Pivot Right HandSTR36SP-SERIES Steering Handles ASSY. Left and Right Steering Handles ASSY, Left and RightGRIP, Handle ROD END, 3/8-24 Male RHHANDLE, Tube HANDLE, STEERING, LowerSTR36SP-SERIES Steering Control ASSY. Left and Right Steering Control ASSY., Left and RightAssist ASSEMBLY, Steering ROD END, 1/2-20 Male RHWASHER, Flat 1/2 SAE WASHER, Lock 3/8 MEDSTR36SP-SERIES Gearbox ASSY. Right Side Gearbox ASSY. Right Side20065 5031A SCREW, RHM 1/4- 20 X 1/2 094812981 20353STR36SP-SERIES Gearbox ASSY. Left Side Gearbox ASSY. Left Side12982 10989 STUD, N10- 32 X 3/4 1290710% 12583 SPACER, X 11D X 1.168L 11%+ 9045 12%+ 0232ASTR36SP-SERIES Single Pitch Handle ASSY. Left and Right Single Pitch Handle ASSY. Left and RightCable Assembly Crank KnobSpacer Crank LeverSTR36SP-SERIES Drive Assy Drive AssyGASKET, CV Joint Boot BOOT, CV JointPLATE, Bearing Mount KEY, Woodruff #9STR36SP-SERIES MUFFLER/BELT Assy MUFFLER/BELT AssyENGINE, Honda 24 HP GX670 MUFFLER, 24 HondaWASHER, Lock 5/16 Medium WASHER, Flat 5/16 USSSTR36SP-SERIES Belt Guard Assy Belt Guard AssyBelt Guard STR36SP-SERIES Spider ASSY. Right Spider ASSY. RightSCREW, Trowel Adjustment Blade AssemblyPLATE, Wear Thrust Collar Wear RingSTR36SP-SERIES Spider ASSY. Left Spider ASSY. LeftLEVER, Trowel ARM Left Hand SPRING, LH Trowel ARM LeverARM, Trowel Left STR36SP-SERIES -YOKE Assy Yoke AssyYoke PIN, YokeSTR36SP-SERIES Foot PEDALS/THROTTLE Assy Foot PEDALS/THROTTLE AssyCABLE, Control 10-32 X 33 Long SPRING, Throttle ReturnWASHER, Flat #10 SAE RISER, Left FootSTR36SP-SERIES Control Panel Assy Control Panel AssySWITCH,TOGGLE Electric #9061 Wire ASSEMBLY, 16 GA. XBOOT, Toggle Switch HARNESS, Wire Honda RiderSTR36SP-SERIES FRAME/FUEL Assy FRAME/FUEL AssyFuel Pump Assembly TANK, Fuel Five GallonFuel CAP/GAUGE BUSHING, Rubber FuelSTR36SP-SERIES Battery Assy Battery AssyBracket Battery HOLD- Down BOLT, Battery Hold DownBOX, Battery GR UI BOOT, TerminalSTR36SP-SERIES Seat Frame Assy Seat Frame AssyCONNECTOR, Relay SWITCH, Kill COLE- HER #90036TERMINAL, Wire Pioneer Seat PlateHonda GX-670 AIR Cleaner Assy AIR Cleaner AssyCLIP, AIR Cleaner SEAL, AIR Cleaner HousingSEAL, AIR Cleaner Cover PLATE, AIR Cleaner SettingHonda GX-670 Camshaft Assy Camshaft AssySPRING, Weight Return SEAL, Valve StemROD, Push ARM, Valve RockerHonda GX-670 Carburetor Assy Carburetor AssyGASKET, AIR Cleaner TUBE, BreatherCLIP, Breather Tube Gasket SETHonda GX-670 Control Assy Control 2 AssyLever ASSEMBLY,THROTTLE JOINT, RODSPRING, Starter ARM, GovernorHonda GX-670 Control BOX Assy Control BOX AssyBRACKET, Wire Harness Clip SUB- Wire Harness Assembly KEY Comp HOLDER, Stop Switch WireSCREW, Special 6 X CLIP, Wire Harness CASE, Control BRACKET, Case MountingHonda GX-670 Crankcase Cover Assy Crankcase Cover AssyCover ASSEMBLY, OIL Pump WEIGHT, GovernorHOLDER, Governor Weight PIN, Governor WeightHonda GX-670 Crankshaft Assy Crankshaft AssyCrankshaft COMP., T-TYPE 90401ZJ1000Honda GX-670 Cylinder Barrel Assy Cylinder BarrelassyCLAMP, Wire SWITCH, OIL PressureCOVER, Breather GASKET, Breather CoverHonda GX-670 Cylinder Head Assy Cylinder Head AssyHANGER, Engine GUIDE, Valve OS, OptionalCLIP, Valve Guide GASKET, Cylinder HeadHonda GX-670 FAN Cover Assy FAN Cover AssyCOVER, FAN *NH1* Black PLATE, Right SidePLATE, Left Side SHROUD, RightHonda GX-670 Flywheel Assy FLY Wheel AssyPLATE, Cooling FAN Setting FAN, CoolingGRID, Screen P.T.O. Optional FLY Wheel CompHonda GX-670 Fuel Pump Assy Fuel Pump AssyPump ASSEMBLY, Fuel STAY, Fuel PumpTUBE, Fuel Tube B, FuelHonda GX-670 Ignition Coil Assy Ignition Coil AssyCoil Assembly R. Ignition GROMMET, Ignition WireCoil ASSEMBLY, L.. Ignition Coil ASSEMBLY, Charge 12V/20AHonda GX-670 Labels Assy Labels AssyHonda GX-670 Labels Assy MARK, EmblemHonda GX-670 OIL Cooler Assy OIL Cooler AssyCollar 12MM Cooler COMP., OILGRILLE, OIL Cooler Hose A, OILHonda GX-670 Piston + Connecting ROD Assy Piston + Connecting ROD AssyROD Assembly Connecting BOLT, Connecting ROD 6 XRing SET, Piston STD Ring SET, Piston 0.75 OptionalHonda GX-670 Starter Motor Assy Starter Motor AssySwitch ASSEMBLY, Magnet RING, Snap DensoCollar SET, Clutch Stop LEVER, Pinion DriveTerms and Conditions of Sale Parts Payment TermsSTR36SP-SERIES-NOTES HERE’S HOW to GET Help