Thermos 461240504 manual Assembly Model No

Page 6

NOTE: Some grill parts shown in the assembly steps may differ slightly in appearance from those on your particular grill model. However, the method of assembly remains the same.

ASSEMBLY – Model No. 461240504

1

First, remove door brace from rear legs. Place door

brace onto front legs as shown. Tabs on brace fit Door brace inside legs. Secure brace to back of front legs using

one 4.2X10mm self-tap screw (ZZ) on each side.

Rear view

Left front leg

Rear view

ZZ

2

Attach locking casters to front legs, non-locking casters to rear legs. Tighten casters using the caster wrench provided.

Caster

wrench

6 • 461240504

Locking casters on front legs.

Image 6

Contents To insure your satisfaction and for follow-up service Installation Safety Precautions Safety SymbolsTable of Contents Description Key Side Shelf AssemblyKey DescriptionParts Diagram Model No Assembly Model No CCC BBB AAA Fully tighten screws inside grill bottom at this time #10-24x3/8 screws DDD, 5mm lock washers EEE Flametamer Pivot wire Smaller basket on left door, larger basket on right door Make sure drain hole is on left side Slide grease receptacle into rails beneath grease tray Very Important LP Tank Removal, Transport And Storage LP Liquefied Petroleum GasLP Tank Filling LP Tank Exchange Connecting Regulator To The LP TankFor your safety LP Tank Leak TestLeak Testing Valves, Hose and Regulator Turn all grill control knobs to OFFSafety Tips For Safe Use Of Your Grill And To Avoid Serious InjuryIgnitor Lighting Ignitor Lighting The Sideburner General Grill CleaningMatch-Lighting Match LightingImmediately turn off gas at LP tank Cleaning The Burner AssemblyStoring Your Grill Wait for grill to coolIndirect Cooking Food SafetyHow To Tell If Meat Is Grilled Thoroughly Indirect Cooking InstructionsTroubleshooting Problem Possible Cause Prevention/SolutionTroubleshooting Electronic Ignition Problem Possible Cause Check Procedure Prevention/SolutionPlease register your grill online at Page 461240504 Division of W.C. Bradley Co. Columbus, GA