Char-Broil 463248708 manual Assembled to Cart, Installation is complete in later steps

Page 16

6

Insert front brace under control panel and between cart side panels with door magnets towards the top. Secure using four 1/4-20x1½”screws, 7mm lock washers, and 7mm flat washers, two on each side.

NOTE: MAKE SURE THAT THE FRONT BRACE IS MOUNTED IN THE MOST DOWNWARD POSITION WHEN

ASSEMBLED TO CART.

7mm flat washer

7mm lock washer

1/4-20x1½” screw

Front brace

7

On back of grill, place upper back panel between side panels and above lower back panel. Secure upper back panel, in lower holes, using one 1/4-20x1½”screw, 7mm lock washer, and 7mm flat washer on each side. Do not fully tighten screws until side shelf

installation is complete in later steps.

1/4-20x1½”	7mm lock	7mm flat
screw	washer	washer

Rear upper panel

16 • 463248708

Image 16

Contents Model 463248708 Product Guide Call Grill Service Center for Help and Parts Installation Safety PrecautionsSafety Symbols For residential use only. Do not use for commercialTable of Contents LP Cylinder Filling LP Liquefied Petroleum GasOnly LP cylinders equipped with this type of valve Connecting Regulator to the LP Cylinder For your safetyUseDo not household cleaning agents. Damage to gas LP Cylinder ExchangeConnection, do not use this regulator Leak Testing Valves, Hose and RegulatorTurn all grill control knobs to OFF For Safe Use of Your Grill and to Avoid Serious Injury Main Burner Ignitor LightingGeneral Grill Cleaning Sideburner Ignitor LightingBurner Flame Check Turning Grill OffCleaning the Burner Assembly Storing Your GrillTurn gas off at control knobs and LP cylinder Very Important Burner tubes must reengage valveFood Safety How To Tell If Meat Is Grilled ThoroughlyRoutine Care Stubborn Stains and RustTools required for assembly Estimated assembly time 30-45 minutesKey DescriptionParts Diagram Model No Front Left Installation is complete in later steps Assembled to CartRemove This Screw View Behind Right Fascia View Behind Right FasciaLarge Flat Washer Remove This Screw View Behind Left FasciaHoles on fascia to Attach valve bracket Holes on fascia to Attach bezelPage Door brace Wire Front of firebox Back of firebox Failure to install grease tray will Damaged in operation, resulting in the risk of fireOn back of grill, slide grease tray into opening Upper back panelTroubleshooting Emergencies Possible Cause Prevention/SolutionElectronic Ignition Troubleshooting Electronic Ignition SectionLimited Warranty Please register your product online at This page intentionally blank This page intentionally blank Grilling Safety Checklist Thank You for Your Purchase