Char-Broil 463247412 manual Auto-Clean

Page 24

Troubleshooting (continued)

Problem

Possible Cause

Prevention/Solution

 

 

 

Burner(s) will not light

ELECTRONIC IGNITION:

• See Section I of Electronic Ignition System.

using ignitor.

• No spark, no ignition noise.

(See Electronic Ignition

• No spark, some ignition noise.

• See Section II of Electronic Ignition System.

Troubleshooting also)

 

• Sparks, but not at electrode or at full

• See Section III of Electronic Ignition System.

 

strength.

 

Burner(s) will not

• See “GAS ISSUES:” on previous page.

 

match light.

• Match will not reach.

• Use long-stem match (fireplace match).

 

 

• Improper method of match-lighting.

• See “Match-Lighting” section of Use and Care.

Sudden drop in gas

• Out of gas.

• Check for gas in LP cylinder.

flow or low flame.

• Excess flow valve tripped.

• Turn off knobs, wait 30 seconds and light grill. If flames are still low,

 

 

 

turn off knobs and LP cylinder valve. Disconnect regulator.

 

 

Reconnect regulator and leak-test. Turn on LP cylinder valve, wait

 

 

30 seconds and then light grill.

 

• Vapor lock at coupling nut/LP cylinder

• Turn off knobs and LP cylinder valve. Disconnect coupling nut from

 

connection.

cylinder. Reconnect and retry.

Flames blow out.

• High or gusting winds.

• Turn front of grill to face wind or increase flame height.

 

• Low on LP gas.

• Refill LP cylinder.

 

• Excess flow valve tripped.

• Refer to “Sudden drop in gas flow” above.

Flare-up.

• Grease buildup.

• Clean burners and inside of grill/firebox.

 

• Excessive fat in meat.

• Trim fat from meat before grilling.

 

• Excessive cooking temperature.

• Adjust (lower) temperature accordingly.

 

 

 

Persistent grease fire.

• Grease trapped by food buildup around

• Turn knobs to OFF. Turn gas off at LP cylinder. Leave lid in position

 

burner system.

and let fire burn out. After grill cools, remove and clean all parts.

 

 

 

Flashback...

• Burner and/or burner tubes are blocked.

• Turn knobs to OFF. Clean burner and/or burner tubes. See burner

(fire in burner tube(s)).

 

cleaning section of Use and Care.

Unable to fill LP

• Some dealers have older fill nozzles

• The worn nozzles don’t have enough “bite” to engage the valve. Try

cylinder.

with worn threads.

a second LP dealer.

One burner does not

• Grease buildup or food particles in

• Clean carry-over tube(s) with wire brush.

light from other

end(s) of carryover tube(s).

 

burner(s).

 

 

AUTO-CLEAN™

Possible Cause

Prevention/Solution

(If Equipped)

 

 

Timer does not work

ŸDead Battery

ŸReplace batteries

(Green light does not

ŸBatteries installed incorrectly.

ŸInstall batteries correctly.

flash)

ŸKnob Position did not start the Clean

ŸPush Knob in to start the clean cycle. (Green LED should begin to

 

Cycle

flash)

 

 

 

No LED’s will illuminate

ŸDead Battery

ŸReplace batteries

 

 

 

Red LED next to battery

ŸLow Battery Strength

ŸPrepare to replace batteries (NOTE: Clean cycle will operate with

symbol is illuminated

 

a weak battery.

 

 

 

24

Page 23 Page 25
Image 24
Page 23 Page 25
Contents Product Guide Date PurchasedTable of Contents This Grill is for Outdoor USE onlyInstallation Safety Precautions California PropositionUSE and Care LP Liquefied Petroleum GasLP Cylinder Filling UL listed Overfill ProtectionFor your safety UseDo not household cleaning agents. Damage to gasLP Cylinder Leak Test Leak Testing Valves, Hose and Regulator Connection, do not use this regulatorTurn all grill control knobs to OFF For Safe Use of Your Grill and to Avoid Serious Injury Ignitor LightingSDo not lean over grill while lighting Open lid during lightingGeneral Grill Cleaning Sideburner Ignitor LightingSideburner Match Lighting Burner Flame CheckCleaning the Burner Assembly Storing Your GrillVery Important Burner tubes must reengage valve Turn gas OFF at control knobs and LP cylinderLimited Warranty Items Manufacturer will not PAY forParts List Key Qty DescriptionParts Diagram Assembly Non-lock casterRear 7mm flat washers on each side Upper back panel Now you may fully tighten lower screws on upper back panel Holes on fascia to Attach valve bracket Holes on fascia to Attach bezelSideburner Ignitor Wire Rear Flame tamers Warming rack Cooking grate Cylinder screw at rear of cart Troubleshooting Emergencies Possible Cause Prevention/SolutionAUTO-CLEAN Troubleshooting Electronic Ignition SectionPage Warranty Registration Department Box Columbus, GA

463247412 specifications

The Char-Broil 463247412 is a standout grill that combines functionality, quality, and innovative technology, making it an excellent choice for both novice and experienced grillers. Designed for versatility and performance, this gas grill boasts several features that enhance the overall cooking experience.

One of its key characteristics is the four stainless steel burners, which deliver a total of 36,000 BTUs of cooking power. Each burner is designed to provide consistent heat across the cooking surface, ensuring that food is cooked evenly. This design allows for precise temperature control, making it easier to achieve that perfect sear on meats or gentle heating for vegetables.

The cooking surface of the Char-Broil 463247412 features a total of 425 square inches, providing ample space to prepare meals for family and friends. Additionally, it comes equipped with a 150 square inch warming rack that allows you to keep your grilled items warm while you finish cooking other dishes. The grates are made of porcelain-coated cast iron, which not only provides excellent heat retention but also makes cleaning a breeze.

One notable technology featured in this grill is the TRU-Infrared cooking system. This innovative system uses infrared heat to cook food more evenly and efficiently. The design helps reduce flare-ups, ensuring a more consistent cooking temperature and retaining the natural juices of the food. The result is juicier meat and enhanced flavors, giving your grilled dishes a restaurant-quality finish.

Furthermore, the Char-Broil 463247412 offers a convenient electronic ignition system, making it easy to start the grill with just the push of a button. This feature eliminates the need for matches or lighter fluid, providing a hassle-free grilling experience. The grill also has a built-in temperature gauge on the lid, allowing you to monitor the internal temperature without having to open the grill and lose heat.

Durability is another important aspect of this model. The grill is constructed with a sturdy stainless steel body designed to withstand the elements, ensuring longevity. The side shelves provide extra workspace and can easily hold grilling tools, seasonings, and prep items.

In summary, the Char-Broil 463247412 is an impressive gas grill that packs a range of features and technologies, from its powerful burners and TRU-Infrared cooking system to its spacious cooking area and durable construction. Whether you’re hosting a backyard barbecue or preparing a family dinner, this grill provides the performance and versatility you need to make every meal a success.
Top Page Image Contents