Char-Broil 463231711 manual Auto-Clean

Page 27

Troubleshooting (continued)

Problem

Possible Cause

Prevention/Solution

 

 

 

Burner(s) will not light

ELECTRONIC IGNITION:

• See Section I of Electronic Ignition System.

using ignitor.

• No spark, no ignition noise.

(See Electronic Ignition

• No spark, some ignition noise.

• See Section II of Electronic Ignition System.

Troubleshooting also)

 

• Sparks, but not at electrode or at full

• See Section III of Electronic Ignition System.

 

strength.

 

Burner(s) will not

• See “GAS ISSUES:” on previous page.

 

match light.

• Match will not reach.

• Use long-stem match (fireplace match).

 

 

• Improper method of match-lighting.

• See “Match-Lighting” section of Use and Care.

Sudden drop in gas

• Out of gas.

• Check for gas in LP cylinder.

flow or low flame.

• Excess flow valve tripped.

• Turn off knobs, wait 30 seconds and light grill. If flames are still low,

 

 

 

turn off knobs and LP cylinder valve. Disconnect regulator.

 

 

Reconnect regulator and leak-test. Turn on LP cylinder valve, wait

 

 

30 seconds and then light grill.

 

• Vapor lock at coupling nut/LP cylinder

• Turn off knobs and LP cylinder valve. Disconnect coupling nut from

 

connection.

cylinder. Reconnect and retry.

Flames blow out.

• High or gusting winds.

• Turn front of grill to face wind or increase flame height.

 

• Low on LP gas.

• Refill LP cylinder.

 

• Excess flow valve tripped.

• Refer to “Sudden drop in gas flow” above.

Flare-up.

• Grease buildup.

• Clean burners and inside of grill/firebox.

 

• Excessive fat in meat.

• Trim fat from meat before grilling.

 

• Excessive cooking temperature.

• Adjust (lower) temperature accordingly.

 

 

 

Persistent grease fire.

• Grease trapped by food buildup around

• Turn knobs to OFF. Turn gas off at LP cylinder. Leave lid in position

 

burner system.

and let fire burn out. After grill cools, remove and clean all parts.

 

 

 

Flashback...

• Burner and/or burner tubes are blocked.

• Turn knobs to OFF. Clean burner and/or burner tubes. See burner

(fire in burner tube(s)).

 

cleaning section of Use and Care.

Unable to fill LP

• Some dealers have older fill nozzles

• The worn nozzles don’t have enough “bite” to engage the valve. Try

cylinder.

with worn threads.

a second LP dealer.

One burner does not

• Grease buildup or food particles in

• Clean carry-over tube(s) with wire brush.

light from other

end(s) of carryover tube(s).

 

burner(s).

 

 

AUTO-CLEAN™

Possible Cause

Prevention/Solution

(If Equipped)

 

 

Timer does not work

ŸDead Battery

ŸReplace batteries

(Green light does not

ŸBatteries installed incorrectly.

ŸInstall batteries correctly.

flash)

ŸKnob Position did not start the Clean

ŸPush Knob in to start the clean cycle. (Green LED should begin to

 

Cycle

flash)

 

 

 

No LED’s will illuminate

ŸDead Battery

ŸReplace batteries

 

 

 

Red LED next to battery

ŸLow Battery Strength

ŸPrepare to replace batteries (NOTE: Clean cycle will operate with

symbol is illuminated

 

a weak battery.

 

 

 

27

Page 26 Page 28
Image 27
Page 26 Page 28
Contents Date Purchased Estimated assembly time 30 minutesThis Grill is for Outdoor USE only Table of ContentsCalifornia Proposition Installation Safety PrecautionsUSE and Care LP Liquefied Petroleum GasLP Cylinder Filling For your safety UseDo not household cleaning agents. Damage to gasLP Cylinder Leak Test Leak Testing Valves, Hose and Regulator Connection, do not use this regulatorTurn all grill control knobs to OFF Open lid during lighting For Safe Use of Your Grill and to Avoid Serious InjuryIgnitor Lighting SDo not lean over grill while lightingBurner Flame Check General Grill CleaningSideburner Ignitor Lighting Sideburner Match LightingTurn gas OFF at control knobs and LP cylinder Cleaning the Burner AssemblyStoring Your Grill Very Important Burner tubes must reengage valveItems Manufacturer will not PAY for Limited WarrantyKey Qty Description Parts ListParts Diagram Assembly Grill head Regulator hose Upper back panel 20x1½ 7mm lock 7mm flat washer Rear of Shelf Now you may fully tighten lower screws on upper back panel Holes on fascia to Page Place sideburner grate and griddle. into sidebruner shelf Front brace AA battery Cap Slide into slots Cooking grate Cylinder screw at rear of cart Emergencies Possible Cause Prevention/Solution TroubleshootingAUTO-CLEAN Section Troubleshooting Electronic IgnitionPage Page Warranty Registration Department Box Columbus, GA

463231711 specifications

The Char-Broil 463231711 is a gas grill that exemplifies excellent performance and user-friendly features, making it a popular choice for grilling enthusiasts. Known for its durability, efficiency, and advanced technology, this grill caters to both novice and experienced cooks alike.

One of the standout features of the Char-Broil 463231711 is its construction. Built with high-quality stainless steel, the grill not only looks sleek but also promises longevity and resistance to the elements. The cooking surface is spacious, boasting 475 square inches of primary cooking space, ideal for preparing meals for family gatherings or barbecues with friends. The grill also includes a 175-square-inch warming rack, enabling you to keep food warm while cooking additional items.

Equipped with powerful burners, the Char-Broil 463231711 utilizes a combination of stainless steel tube burners that deliver a total of 36,000 BTUs of cooking power. This allows for efficient heat distribution, ensuring that food is cooked uniformly. Additionally, the grill features Char-Broil's TRU-Infrared technology, which enhances heat retention and minimizes flare-ups. This innovative technology ensures that food retains its natural juices, resulting in tender and flavorful meals.

Another excellent feature is the electronic ignition system, which provides reliable starting with just the push of a button. This convenience is invaluable for those who want a quick setup without the hassle of matches or lighters. The grill's control panel is designed for user-friendliness, with easy-to-read temperature gauges and knobs that allow you to adjust the heat precisely.

The Char-Broil 463231711 also boasts ample storage solutions, including shelves on either side of the grill, providing a convenient place for condiments, tools, and other grilling essentials. The grill’s durable wheels make it mobile, allowing you to easily move it around your patio or backyard.

In summary, the Char-Broil 463231711 stands out with its durable construction, spacious cooking area, and advanced features like TRU-Infrared technology and electronic ignition. With its combination of performance, convenience, and longevity, it is an excellent investment for anyone serious about outdoor cooking. Whether you are grilling burgers for a weekend cookout or preparing elaborate meals for gatherings, this grill delivers consistent results that will impress your guests.
Top Page Image Contents