Char-Broil 463231711 For Safe Use of Your Grill and to Avoid Serious Injury, Ignitor Lighting

Page 7

WARNING

For Safe Use of Your Grill and to Avoid Serious Injury:

•Do not let children operate or play near grill.

•Keep grill area clear and free from materials that burn.

•Do not block holes in sides or back of grill.

•Check burner flames regularly.

•Use grill only in well-ventilated space. NEVER use in enclosed space such as carport, garage, porch, covered patio, or under an overhead structure of any kind.

•Do not use charcoal or ceramic briquets in a gas grill. (Unless briquets are supplied with your grill.)

•Use grill at least 3 ft. from any wall or surface. Maintain 10 ft. clearance to objects that can catch fire or sources of ignition such as pilot lights on water heaters, live electrical appliances, etc.

•Apartment Dwellers:

Check with management to learn the requirements and fire codes for using an LP gas grill in your apartment complex. If allowed, use outside on the ground floor with a three (3) foot clearance from walls or rails. Do not use on or under balconies.

•NEVER attempt to light burner with lid closed. A buildup of non-ignited gas inside a closed grill is hazardous.

•Never operate grill with LP cylinder out of correct position specified in assembly instructions.

•Always close LP cylinder valve and remove coupling nut before moving LP cylinder from specified operation position.

Safety Tips

sBefore opening LP cylinder valve, check the coupling nut for tightness.

sWhen grill is not in use, turn off all control knobs and LP cylinder valve.

sNever move grill while in operation or still hot. Uselong-handled barbecue utensils and oven mitts to avoid

burns and splatters.

sMaximum load for sideburner and side shelf is 10 lbs.

greaseThe tray must be inserted into grill and emptied after each use. Do not remove grease tray until grill has completely cooled.

sClean grill often, preferably after each cookout. If a bristle brush is used to clean any of the grill cooking surfaces, ensure no loose bristles remain on cooking surfaces prior to grilling. It is not recommended to clean cooking surfaces while grill is hot.

sIf you notice grease or other hot material dripping from grill onto valve, hose or regulator, turn off gas supply at once. Determine the cause, correct it, then clean and inspect valve, hose and regulator before continuing. Perform a leak test.

sKeep ventilation openings in cylinder enclosure (grill cart) free and clear of debris.

sDo not store objects or materials inside the grill cart enclosure that would block the flow of combustion air to the underside of either the control panel or the firebox bowl.

sThe regulator may make a humming or whistling noise during operation. This will not affect safety or use of grill.

sIf you have a grill problem see the "Troubleshooting Section". sIf the regulator frosts, turn off grill and LP cylinder valve

immediately. This indicates a problem with the cylinder and it should not be used on any product. Return to supplier!

CAUTION

•Putting out grease fires by closing the lid is not possible. Grills are well ventilated for safety reasons.

•Do not use water on a grease fire. Personal injury may result. If a grease fire develops, turn knobs and LP cylinder off.

•Do not leave grill unattended while preheating or burning off food residue on HI. If grill has not been regularly cleaned, a grease fire can occur that may damage the product.

Ignitor Lighting

sDo not lean over grill while lighting.

1.Turn OFF gas burner control valves.

2.Turn ON gas at LP cylinder.

3.Open lid during lighting.

4.To ignite, push and turn ignition burner knob to HI.

5. .Push and hold ELECTRONIC IGNITION button until the burner lights.

6.If ignition does NOT occur in 5 seconds, turn the burner controls OFF, wait 5 minutes and repeat the lighting procedure.

7.To ignite remaining burners, turn knob to the HI position starting with the burners closest to IGNITION BURNERS first. If ignitor does not work, follow match lighting instructions.

Lighting instructions are continued on the next page

7

Page 6 Page 8
Image 7
Page 6 Page 8
Contents Date Purchased Estimated assembly time 30 minutesThis Grill is for Outdoor USE only Table of ContentsCalifornia Proposition Installation Safety PrecautionsLP Liquefied Petroleum Gas USE and CareLP Cylinder Filling UseDo not household cleaning agents. Damage to gas For your safetyLP Cylinder Leak Test Connection, do not use this regulator Leak Testing Valves, Hose and RegulatorTurn all grill control knobs to OFF Open lid during lighting For Safe Use of Your Grill and to Avoid Serious InjuryIgnitor Lighting SDo not lean over grill while lightingBurner Flame Check General Grill CleaningSideburner Ignitor Lighting Sideburner Match LightingTurn gas OFF at control knobs and LP cylinder Cleaning the Burner AssemblyStoring Your Grill Very Important Burner tubes must reengage valveItems Manufacturer will not PAY for Limited WarrantyKey Qty Description Parts ListParts Diagram Assembly Grill head Regulator hose Upper back panel 20x1½ 7mm lock 7mm flat washer Rear of Shelf Now you may fully tighten lower screws on upper back panel Holes on fascia to Page Place sideburner grate and griddle. into sidebruner shelf Front brace AA battery Cap Slide into slots Cooking grate Cylinder screw at rear of cart Emergencies Possible Cause Prevention/Solution TroubleshootingAUTO-CLEAN Section Troubleshooting Electronic IgnitionPage Page Warranty Registration Department Box Columbus, GA

463231711 specifications

The Char-Broil 463231711 is a gas grill that exemplifies excellent performance and user-friendly features, making it a popular choice for grilling enthusiasts. Known for its durability, efficiency, and advanced technology, this grill caters to both novice and experienced cooks alike.

One of the standout features of the Char-Broil 463231711 is its construction. Built with high-quality stainless steel, the grill not only looks sleek but also promises longevity and resistance to the elements. The cooking surface is spacious, boasting 475 square inches of primary cooking space, ideal for preparing meals for family gatherings or barbecues with friends. The grill also includes a 175-square-inch warming rack, enabling you to keep food warm while cooking additional items.

Equipped with powerful burners, the Char-Broil 463231711 utilizes a combination of stainless steel tube burners that deliver a total of 36,000 BTUs of cooking power. This allows for efficient heat distribution, ensuring that food is cooked uniformly. Additionally, the grill features Char-Broil's TRU-Infrared technology, which enhances heat retention and minimizes flare-ups. This innovative technology ensures that food retains its natural juices, resulting in tender and flavorful meals.

Another excellent feature is the electronic ignition system, which provides reliable starting with just the push of a button. This convenience is invaluable for those who want a quick setup without the hassle of matches or lighters. The grill's control panel is designed for user-friendliness, with easy-to-read temperature gauges and knobs that allow you to adjust the heat precisely.

The Char-Broil 463231711 also boasts ample storage solutions, including shelves on either side of the grill, providing a convenient place for condiments, tools, and other grilling essentials. The grill’s durable wheels make it mobile, allowing you to easily move it around your patio or backyard.

In summary, the Char-Broil 463231711 stands out with its durable construction, spacious cooking area, and advanced features like TRU-Infrared technology and electronic ignition. With its combination of performance, convenience, and longevity, it is an excellent investment for anyone serious about outdoor cooking. Whether you are grilling burgers for a weekend cookout or preparing elaborate meals for gatherings, this grill delivers consistent results that will impress your guests.
Top Page Image Contents