Char-Broil 463666510 manual Assembly, Align holes

Page 17

ASSEMBLY

1

Insert lower cart legs into cart legs, make sure the holes for tank exclusion wire face inside, and the holes on lower cart legs are aligned to the lower holes on cart legs. Position leg assemblies as shown below. Attach front panel, side support braces and back brace to legs using eight 1/4’’-20x2” carriage bolts and four 1/4’’-20 tee knobs. Do not fully tighten all tee knobs until step5.

Front panel

Side support

brace

1/4’’-20x2”

Carriage Bolt

Qty. 8

Back brace

1/4’’-20 Tee Knob

Qty. 8Holes for tank exclusion wire face inside

Align holes

2

Turn assembly upside-down. Insert 5/16’’ axle bolts into wheels. Facing the back, position tank support bracket between left legs. Insert axle bolt through leg and bracket and secure with hitch pin.

5/16”

5/16’’ Axle Bolts

Hitch Pin

Qty. 2

Wheel

Tank support

bracket

Axle Bolt

Qty. 2

“Cone” side of wheel against leg.

17

Image 17

Contents Date Purchased Estimated assembly time 45 minutesThis Grill is for Outdoor USE only Table of ContentsCalifornia Proposition Installation Safety PrecautionsFirst Time Use TemperatureLava Rock / Briquettes Pre-Heating Your GrillDirect Cooking Food SafetyIndirect Cooking Rotisserie CookingUsda Recommended Safe Minimum Internal Temperatures General Cleaning Why Clean?Routine Care Storing Your GrillLP Cylinder Filling USE and CareLP Liquefied Petroleum Gas LP Cylinder Leak Test For your safetyUseDo not household cleaning agents. Damage to gas Turn all grill control knobs to OFF Leak Testing Valves, Hose and RegulatorConnection, do not use this regulator For Safe Use Of Your Grill And To Avoid Serious Injury Safety TipsGeneral Grill Cleaning Turn controls and gas source or tank OFF when notIgnitor Lighting UseTurn gas OFF at control knobs and LP cylinder Cleaning the Burner AssemblyStoring Your Grill All Parts Year from date of purchase Limited WarrantyKey Qty Description Parts ListParts Diagram Align holes AssemblyQty Push Fastener Qty Qty Qty.2 ’’-20 Flange Nut Lid assembly ’’-20x2’’ Carriage Bolt Qty.1 Not included Emergencies Possible Cause Prevention/Solution TroubleshootingPiezo PUSH-BUTTON and Rotary Page Warranty Registration Department Box Columbus, GA