Char-Broil 10201597-50 manual Ignitor Lighting, View is from side of appliance Burner Flame Check

Page 8

Ignitor Lighting

•Do not lean over appliance while lighting.

1. Turn ON LP gas cylinder.

2.Open the Smoke Chamber door.

3.Press and turn the control knob to HIGH.

4.Turn ROTARY IGNITOR knob rapidly.

5.Pull out the Firebox Drawer to verify that the burner is lit.

6.If ignition does not occur in 5 seconds, turn the burner control knob OFF, wait 5 minutes, and repeat lighting procedure.

If ignition still does not occur, follow match-lighting instructions.

WARNING

Turn control knob and LP cylinder OFF when not in use.

CAUTION

If ignition does NOT occur in 5 seconds, turn the control knob OFF, wait 5 minutes and repeat the lighting procedure. If the burner does not ignite with the valve open, gas will continue to flow out of the burner and could accidently ignite with risk of injury.

Match-Lighting

Do not lean over appliance while lighting.

1.Turn ON LP cylinder.

2.Open the Smoke Chamber door.

3.Place lit match into match lighting hole of appliance as pictured below. Make sure lit match is placed inside hole and near burner.

4. Push in and turn control knob to HIGH.

 

Be sure burner

lights and stays lit.

 

 

 

 

5.Pull out the Firebox Drawer to verify that the burner is lit.

First - Open

Match

the door

 

Lighting

Firebox

Hole

Drawer

 

Control

Match

Knob

 

View is from side of appliance

8 • 10201597-50

Burner Flame Check

•Light burner, rotate knob from HIGH to LOW. Looking through the match light holes underneath the appliance, you should see the flame height decrease when turning knob from HIGH to LOW. Always check flame prior to each use. If only low flame is seen refer to "Sudden drop or low flame" in the Troubleshooting Section.

Turning Appliance Off

•Turn control knob to OFF position. Turn LP cylinder off by turning hand-wheel clockwise to a full stop.

Ignitor Check

•Turn gas off at LP cylinder. Turn ignitor knob. "Click" should be heard each time at electrode. See "Troubleshooting" if no click or spark.

Valve Check

•Important: Make sure gas is off at LP cylinder before checking valve. Knob locks in OFF position. To check valve, first push in knob and release, knob should spring back. If knob does not spring back, replace valve assembly before using Oil- less Fryer. Turn knob to HIGH position then turn back to OFF position. Valve should turn smoothly.

Hose Check

•Before each use, check to see if hose is cut, worn or kinked. Replace damaged hose before using applaince. Use only valve/hose/regulator specified by manufacturer.

NormalKinked

HoseHose

General Appliance Cleaning

•Do not mistake brown or black accumulation of grease and smoke for paint. Interiors are not painted at the factory (and should never be painted). Apply a strong solution of detergent and water or use a grill cleaner with scrub brush on insides of appliance lid and bottom. Rinse and allow to completely air dry.

Do not apply a caustic grill/oven cleaner to painted surfaces.

•Plastic parts: Wash with warm soapy water and wipe dry. Do not use citrisol, abrasive cleaners, degreasers or a concentrated grill cleaner on plastic parts. Damage to and failure of parts can result.

•Painted surfaces: Wash with mild detergent or non-abrasive cleaner and warm soapy water. Wipe dry with a soft non- abrasive cloth.

•Stainless steel surfaces: To maintain the high quality appearance, wash with mild detergent and warm soapy water and wipe dry with a soft cloth after each use. Baked-on grease deposits may require the use of an abrasive plastic cleaning pad. Use only in direction of brushed finish to avoid damage. Do not use abrasive pad on areas with graphics.

•Cooking surfaces: If a bristle brush is used to clean any of the grill cooking surfaces, ensure no loose bristles remain on cooking surfaces prior to grilling. It is not recommended to clean cooking surfaces while grill is hot.

Page 7 Page 9
Image 8
Page 7 Page 9
Contents Date Purchased Estimated time to complete assembly 1 hour Do not assemble without a helperFor residential use only. Do not use for commercial Installation Safety PrecautionsCooking Table of Contents USE and Care LP Cylinder Removal, Transport and StorageLP Liquefied Petroleum Gas LP Cylinder FillingLP Cylinder Leak Test For your safetyUseDo not household cleaning agents. Damage to gas Turn control knob to OFF Leak Testing Valves, Hose and RegulatorConnection, do not use this regulator For Safe Use of Your CB600x and to Avoid Serious Injury General Appliance Cleaning Ignitor LightingView is from side of appliance Burner Flame Check Turning Appliance OffCleaning the Burner Assembly Spider AlertFood Safety How To Tell If Meat Is Cooked ThoroughlySafety Precautions while cooking Water LevelWater or Juice? Setup Instructions Using Wood Chips or ChunksWood Chips Water Reservoir Or Chunks Parts Diagram Key Qty DescriptionAssembly Control Valve Qty #1/4-20x1/2 Hex Head Bolt 20X3/4 screws Thermometer Wing Nut Troubleshooting Emergencies Possible Cause Prevention/SolutionProblem Possible Cause Prevention/Solution Limited Warranty All Parts DaysLimited Warranty Page Warranty Registration Department Box Columbus, GA

10201597-50 specifications

The Char-Broil 10201597-50 is an innovative outdoor grill that embodies exceptional performance and user-friendly design, making it an ideal choice for both novice and seasoned grilling enthusiasts. This model is a standout in the Char-Broil lineup, known for its quality craftsmanship and advanced technologies.

One of the main features of the 10201597-50 is its reliable TRU-Infrared technology. This unique cooking system uses infrared heat to cook food evenly, reducing hot and cold spots commonly found in traditional grills. The result is perfectly grilled meats and vegetables without the risk of flare-ups or charring. This technology also allows for better heat retention, ensuring that food cooks faster while using less fuel.

The grill boasts a generous cooking surface with a total of 450 square inches, including a primary cooking area that allows for ample space to prepare meals for family and friends. The porcelain-coated grates provide excellent heat retention and are easy to clean, making maintenance a breeze. Furthermore, the grilling area is complemented by a side burner, which brings additional cooking versatility, enabling users to prepare sauces or sides while grilling.

Another characteristic that sets the Char-Broil 10201597-50 apart is its sturdy construction. The grill features a durable stainless-steel finish that not only adds to its aesthetic appeal but also enhances its longevity in various weather conditions. With a cabinet design that houses the propane tank conveniently and a side shelf for additional food preparation space, the design is both functional and stylish.

Ease of use is prioritized in this model, as it comes equipped with an electronic ignition system. This feature ensures quick and reliable start-up, eliminating the frustration of manual ignition processes. Additionally, the temperature gauge mounted on the lid allows for real-time monitoring of the cooking temperature, providing more control over the grilling process.

Finally, the Char-Broil 10201597-50 provides great value for money, merging advanced grilling technology with an accessible price point. It appeals to those who desire high-quality performance without breaking the bank. With its innovative features, robust design, and user-friendly characteristics, the Char-Broil 10201597-50 is poised to elevate any outdoor cooking experience. Whether you're hosting a barbecue or enjoying a quiet evening meal, this grill is ready to deliver delicious results time and time again.
Top Page Image Contents