Char-Broil 463821908 manual Troubleshooting, Emergencies Possible Cause Prevention/Solution

Page 21

EMERGENCIES: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department.

Emergencies

Possible Cause

Prevention/Solution

 

 

 

Gas leaking from

• Damaged hose.

• Turn off gas at LP tank or at source on natural gas systems. If

cracked/cut/burned

 

anything but burned, replace valve/hose/regulator. If burned,

hose.

 

discontinue use of product until a plumber has investigated cause

 

 

and corrections are made.

Gas leaking from LP

• Mechanical failure due to rusting or

• Replace LP tank.

tank.

mishandling.

 

Gas leaking from LP

• Failure of tank valve from mishandling or

• Turn off LP tank valve. Return LP tank to gas supplier.

tank valve.

mechanical failure.

 

Gas leaking between

• Improper installation, connection not

• Turn off LP tank valve. Remove regulator from tank and visually

LP tank and regulator

tight, failure of rubber seal.

inspect rubber seal for damage. See LP tank Leak Test and

connection.

 

Connecting Regulator to the LP tank.

Fire coming through

• Fire in burner tube section of burner due

• Turn off control knobs and LP tank valve. Leave lid open to allow

control panel.

to blockage.

flames to die down. After fire is out and grill is cold, remove burner

 

 

and inspect for spider nests or rust. See Natural Hazard and

 

 

Cleaning the Burner Assembly pages.

Grease fire or

• Too much grease buildup in burner area.

• Turn off control knobs and LP tank valve. Leave lid open to allow

continuous excessive

 

flames to die down. After cooling, clean food particles and excess

flames above cooking

 

grease from inside firebox area, grease cup, and other surfaces.

surface.

 

 

 

 

 

Troubleshooting

Problem

Burner(s) will not light using ignitor.

Continued on next page.

Possible Cause

GAS ISSUES:

•Trying to light wrong burner.

•Burner not engaged with control valve.

•Obstruction in burner.

•No gas flow.

•Vapor lock at coupling nut to LP tank.

•Coupling nut and LP tank valve not fully connected.

ELECTRICAL ISSUES:

•Electrode cracked or broken; “sparks at crack.”

•Electrode tip not in proper position.

•Wire and/or electrode covered with cooking residue.

•Wires are loose or disconnected.

•Wires are shorting (sparking) between ignitor and electrode.

Prevention/Solution

•See instructions on control panel and in Use and Care section.

•Make sure valves are positioned inside of burner tubes.

•Ensure burner tubes are not obstructed with spider webs or other matter. See cleaning section of Use and Care.

•Make sure LP tank is not empty. If LP tank is not empty, refer to “Sudden drop in gas flow.”

•Turn off knobs and disconnect coupling nut from LP tank. Reconnect and retry.

•Turn the coupling nut approximately one-half to three-quarters additional turn until solid stop. Tighten by hand only - do not use tools.

•Replace electrode(s).

Main Burners:

•Tip of electrode should be pointing toward gas port opening on burner. The distance should be 1/8” to 1/4”. Adjust if necessary.

Sideburner (if featured):

•Tip of electrode should be pointing toward gas port opening on burner. the distance should be 1/8” to 3/16”. Adjust if necessary.

•Clean wire and/or electrode with rubbing alcohol and clean swab.

•Reconnect wires or replace electrode/wire assembly.

•Replace ignitor wire/electrode assembly.

463821908 • 21

Page 20 Page 22
Image 21
Page 20 Page 22
Contents Model 463821908 Product Guide Installation Safety Precautions Call Grill Service Center for Help and PartsSafety Symbols For residential use only. Do not use for commercialTable of Contents LP Liquefied Petroleum Gas LP tank Removal, Transport and StorageLP tank Filling Only LP tanks equipped with this type of valveFor your safety Connecting Regulator to the LP tankUseDo not household cleaning agents. Damage to gas LP tank ExchangeLeak Testing Valves, Hose and Regulator Turn all grill control knobs to OFFConnection, do not use this regulator For Safe Use of Your Grill and to Avoid Serious Injury Ignitor Lighting General Grill CleaningBurner Flame Check Turning Grill OffStoring Your Grill Cleaning the Burner AssemblyTurn gas off at control knobs and LP tank Burner Tube Valve Correct burner-to-valve engagementHow To Tell If Meat Is Grilled Thoroughly Food SafetyDescription Description KeyParts Diagram Model No Cone side of wheel against leg Axle Bolt Qty.2 Leg Extender#10-24 X Machine Screw Qty.4 #10-24 Flange Nut #10-24 x ½ Machine Screws Machine screws and silicon washersMetal Qty Sideburner Grate Ignitor wire ClipTool Holder Sideburner Flange Nut Screw#10-24 #10-24 Wing Screw QtyFlange Nuts Qty8 #10-24 X ½ Qty4 Machine Screw Lower Hinge Center flat portion of hinge on bottomPage Cooking Grate Heat Tent Pivot Wire Swing Away LegTank Wire Emergencies Possible Cause Prevention/Solution TroubleshootingPiezo PUSH-BUTTON and Rotary Limited warranty Limited WarrantyIntentionally Blank Intentionally Blank Intentionally Blank Envíelo a Please register your grill online atThank You for Your Purchase Grilling Safety Checklist

463821908 specifications

The Char-Broil 463821908 is a highly regarded gas grill that offers exceptional performance and versatility for outdoor cooking enthusiasts. With a sleek design and user-friendly features, this grill is perfect for backyard barbecues or family gatherings.

One of the standout features of the Char-Broil 463821908 is its four stainless steel burners, which deliver a total of 36,000 BTUs of cooking power across the main grilling area. This allows for ample cooking space, making it easy to prepare meals for larger groups. The grill also includes a side burner, providing an additional 10,000 BTUs, perfect for simmering sauces or preparing side dishes while grilling.

The cooking surface features a generous 480 square inches of primary grilling space, complemented by a warming rack that adds another 180 square inches. This combination allows for efficient meal preparation, giving users the ability to cook multiple items simultaneously without compromising on quality.

Durability is a key characteristic of the Char-Broil 463821908, as it is constructed with a combination of stainless steel and durable porcelain-coated grates, contributing to its longevity and ease of maintenance. The porcelain-coated cast iron grates allow for excellent heat retention and distribution, ensuring evenly cooked food with those classic grill marks.

Char-Broil's innovative TRU-Infrared cooking technology is another defining feature of this grill. This technology helps to eliminate flare-ups and provides even heat distribution, resulting in juicier steaks and perfectly cooked burgers. TRU-Infrared cooking also enhances fuel efficiency, allowing users to accomplish more with less propane, maximizing grilling time.

In terms of convenience, the Char-Broil 463821908 includes an easy-to-read lid-mounted temperature gauge, ensuring precise cooking control. The grill is also equipped with a quick start electronic ignition system, allowing for effortless startups. Further enhancing usability, the grill features side shelves for added workspace, perfect for prep and serving.

For those seeking a reliable, efficient, and user-friendly gas grill, the Char-Broil 463821908 stands out with its combination of features, durability, and innovative technologies, making it an excellent choice for grilling aficionados. Whether you are a seasoned griller or just starting, this model is designed to deliver an unparalleled cooking experience.
Top Page Image Contents