Char-Broil 463722413 Ignitor Lighting, Turn controls and gas source or tank OFF when not, Use

Page 12

Ignitor Lighting

▲Do not lean over grill while lighting.

1. Turn OFF gas burner control valves.

2. Turn ON gas at LP cylinder.

3. Open lid during lighting.

4. To ignite, turn left knob to the HIGH position.

5. Push IGNITOR button rapidly.

6.If ignition does NOT occur in 5 seconds, turn the burner

controls OFF, wait 5 minutes and repeat the lighting procedure.

7.To ignite right burner, turn knob to the HIGH position.

If ignitor does not work, follow match lighting instructions. After Lighting: Turn knobs to HIGH position for warm-up.

WARNING

Turn controls and gas source or tank OFF when not

in use.

CAUTION

If burner does not light, turn knobs to OFF, wait 5 minutes, and try again. Always close valve during the 5 minute waiting period. If the burner does not ignite with the valve open, gas will continue to flow out of the burner and could accidentally ignite with risk of injury.

Match-Lighting

▲Do not lean over grill while lighting.

1.Turn OFF gas burner control valves.

2.Turn ON gas at LP cylinder.

3.Open lid during lighting.

4.Place match into match holder (hanging from side of cart). Strike the match.

5.Place lit match through the match light hole and near the burner. Push in and turn left knob to the HIGH position.

Be sure the burner lights and stays lit.

6.Light right burner by pushing knob in and turning to the HIGH position.

NOTE: Your grill may NOT be equipped with a Sideburner!

Sideburner Ignitor Lighting

1.Turn OFF gas burner control valves.

2.Turn ON gas at LP cylinder.

3.To ignite SIDEBURNER, open sideburner cover.

4.Turn sideburner knob to the HIGH position. Push IGNITOR button rapidly.

5.If sideburner does not light in 5 seconds, turn knob to OFF, wait 5 minutes, then repeat lighting procedure.

Sideburner Match Lighting

1.Turn ON gas at LP cylinder.

2.Hold lit match to any port on the burner. Push in and turn sideburner knob to the HIGH position.

Be sure burner lights and stays lit.

Burner Flame Check

•Remove cooking grates and flametamers. Light burner, rotate knobs from HIGH to LOW. You should see

a smaller flame in LOW position than seen on HIGH. Always check flame prior to each use. If only low flame is seen refer to "Sudden drop or low flame" in the Troubleshooting Section.

HIGH

LOW

Hose Check

•Before each use, check to see if hoses are cut, worn or kinked. Replace damaged hoses before using grill. Use only valve/hose/regulator specified in the Parts List.

Turning Grill Off

•Turn all knobs to OFF position. Turn LP tank off by turning OPD hand wheel clockwise to a full stop.

Ignitor Check

•Turn gas off at LP tank. Press and hold ignitor button. "Click" should be heard and spark seen each time between collector box or burner and electrodes. See "Troubleshooting" if no click or spark.

Valve Check

•Important: Make sure gas is off at LP tank before checking valves. Knobs lock in OFF position. To check valves, first push in knobs and release, knobs should spring back. If knobs do not spring back, replace valve assembly before using grill. Turn knobs to LOW position then turn back to OFF position. Valves should turn smoothly.

General Grill Cleaning

•Do not mistake brown or black accumulation of grease and smoke for paint. Interiors of gas grills are not painted at the factory (and should never be painted). Apply a strong solution of detergent and water or use a grill cleaner with scrub brush on insides of grill lid and bottom. Rinse and allow to completely air dry. Do not apply a caustic grill/oven cleaner to painted surfaces.

•Plastic parts: Wash with warm soapy water and wipe dry.

s Do not use citrisol, abrasive cleaners, degreasers or a concentrated grill cleaner on plastic parts. Damage to and failure of parts can result.

•Porcelain surfaces: Because of glass-like composition, most residue can be wiped away with baking soda/water solution or specially formulated cleaner. Use nonabrasive scouring powder for stubborn stains.

•Painted surfaces: Wash with mild detergent or nonabrasive cleaner and warm soapy water. Wipe dry with a soft nonabrasive cloth.

12

Page 11 Page 13
Image 12
Page 11 Page 13
Contents Product Guide Date PurchasedTable of Contents This Grill is for Outdoor USE onlyInstallation Safety Precautions California PropositionTemperature Convective Grills only First Time UseLava Rock / Briquettes Pre-Heating Your GrillFood Safety Direct CookingIndirect Cooking Rotisserie CookingUsda Recommended Safe Minimum Internal Temperatures Why Clean? General CleaningRoutine Care Storing Your GrillUSE and Care LP Liquefied Petroleum GasLP Cylinder Filling UL listed Overfill ProtectionFor your safety LP Cylinder Leak TestLeak Testing Valves, Hose and Regulator Connection, do not use this regulatorTurn all grill control knobs to OFF Safety Tips For Safe Use of Your Grill and to Avoid SeriousInjury Use grill at least 3 ft. from any wall or surfaceTurn controls and gas source or tank OFF when not General Grill CleaningIgnitor Lighting UseCleaning the Burner Assembly Storing Your GrillTurn gas OFF at control knobs and LP cylinder Limited Warranty Items Manufacturer will not PAY forParts List Key Qty DescriptionParts Diagram Assembly Left legRight leg Front Panel Wheel Control Panel and Firebox Supports Valve / Hose / Regulator and IgnitorTank Retainer Burner and Firebox and Control Knobs Shelves Sideburner Center flat portion Lid Handle and Upper HingesLid Heat TentCooking Grate Correctly Installed LP cylinder Swing AwayGrease Cup and Grease Cup Clip Troubleshooting Emergencies Possible Cause Prevention/SolutionPiezo PUSH-BUTTON and Rotary Page Mail to / Enviar a / Envoyer à Special Offer

463722413 specifications

The Char-Broil 463722413 is a premier gas grill designed for the grilling enthusiast seeking a combination of performance, durability, and style. This model stands out in the market due to its impressive features and advanced technologies that enhance cooking efficiency and user experience.

One of the defining features of the Char-Broil 463722413 is its robust construction. The grill is built with high-grade stainless steel that not only ensures longevity but also gives it a sleek, modern appearance. The durable material is resistant to rust and corrosion, making it ideal for various weather conditions. Additionally, the grill includes a porcelain-coated grease pan, designed for easy cleanup and improved hygiene, allowing users to focus on cooking rather than post-grill maintenance.

Equipped with four stainless steel burners, the Char-Broil 463722413 delivers an impressive total output of 36,000 BTUs. Each burner is individually controlled, enabling users to create different heat zones on the grilling surface. This versatility allows for perfect searing as well as lower-temperature cooking for items that require gentle heat, providing a range of cooking options from burgers and steaks to vegetables and seafood.

Another remarkable technology in this model is the TRU-Infrared cooking system. This innovative feature ensures even heat distribution across the cooking surface, preventing hot or cold spots that can lead to uneven cooking. The infrared technology also minimizes flare-ups, preserving the juices and flavors of the food, creating a moist and delicious end product.

The Char-Broil 463722413 grill also comes equipped with a large primary cooking area of 450 square inches, complemented by an additional warming rack. This generous cooking space is perfect for entertaining guests or preparing a feast for the family. The side shelves provide ample prep space and feature integrated hooks, allowing for easy access to grilling tools and utensils.

Convenience is further enhanced by the grill’s electronic ignition system, allowing for quick and easy starts without the hassle of matches or lighters. The addition of wheels ensures portability, allowing users to maneuver their grill into position for cooking or store it easily when not in use.

In summary, the Char-Broil 463722413 is a high-performance gas grill that excels in construction, cooking technology, and user-friendly features. With its durable materials, ample cooking space, and innovative TRU-Infrared system, this grill is designed for those who appreciate quality and efficient grilling. Whether you are a seasoned backyard chef or a novice griller, the Char-Broil 463722413 promises to deliver exceptional results, making it a worthy addition to any outdoor cooking setup.
Top Page Image Contents