Weber LP GAS GRILL manual Manually Lighting the Smoker Burner

Operating Instructions

Manually Lighting the Smoker Burner 1

	WARNING: Check hose before each use of grill for
nicks, cracking, abrasions or cuts. If the hose is found			2,3,10
to be damaged in any way, do not use the grill.
Replace using only Weber® authorized replacement
hose. Contact the Customer Service Representative in
your region using the contact information sheet		8	7,9
provided with your manual.
1)	Open the lid.

DANGER	4	5
Failure to open the lid while igniting the grill, or not
waiting 5 minutes to allow the gas to clear if the grill
does not light, may result in an explosive flare-up
which can cause serious bodily injury or death.	4
2) Open smoker box lid	*The grill illustrated may have slight differences than the
3) Fill smoker with water soaked wood chunks or chips.
4) Make sure all burner control knobs are turned OFF.	model purchased.
(Push control knob down and turn clockwise to ensure
that it is in the OFF position.)	5) Turn the cylinder on by turning the cylinder valve
WARNING: The burner control knobs must be in the	counterclockwise.
OFF position before turning on the liquid propane	6) Put a match in the match holder and strike the match.
cylinder tank valve. If they are not in the OFF position,	7) Insert match holder and lit match down through
when you turn on the LP cylinder valve, the “excess	cooking grates and Flavorizer® bars to ignite smoker
gas flow control” feature will activate, limiting the flow	burner.
of gas from the LP cylinder. If this should occur, turn	WARNING: Do not lean over the open grill while
OFF the LP cylinder valve and burner control knobs.	lighting.
Then start over.	8) Push smoker burner control knob down and turn to
DANGER:	START / HI.
	9) Check that the burner is lit by looking down through
When the “excess gas flow control” feature is
	the cooking grate.
activated, a small amount of gas is still flowing to the
burners. After turning OFF the cylinder and burner	DANGER:
control knobs, wait at least 5 minutes for the gas to
	If the smoker burner does not light, turn the burner
clear before attempting to light the grill. Failure to do
	control knob to OFF and wait 5 minutes to let the gas
so may result in an explosive flare-up, which can
	clear before you try again or try to light with a match.
cause serious bodily injury or death.
	10) Close smoker cover after wood starts to smolder and
	turn control knob to low.

To Extinguish

Push down and turn each burner control knob clockwise to

OFF position. Turn gas supply OFF at the source.

D-8