Weber S-640 - NG manual Grilling Tips & Helpful Hints, Snap Ignition Operation

12 OPERATING INSTRUCTIONS

GRILLING TIPS & HELPFUL HINTS

•Always preheat the grill before cooking. Set all burners on “HI” heat and close lid; heat for 10 minutes, or until thermometer registers 500˚-550˚F (260˚-288˚C).

•Sear meats and cook with the lid down for perfectly grilled food every time.

•Grilling times in recipes are based on 70˚F (20˚C) weather and little or no wind. Allow more cooking time on cold or windy days, or at higher altitudes. Allow less cooking time in extremely hot weather.

•Grilling times can vary because of the weather, or the amount, size and shape of the food being grilled.

•The temperature of your Summit® gas grill may run hotter than normal for the fi rst few uses.

•Grilling conditions may require the adjustment of the burner controls to attain the correct cooking temperatures.

•In general, large pieces of meat will require more cooking time per pound than small pieces of meat. Foods on a crowded cooking grate will require more cooking time than just a few foods. Foods grilled in containers, such as baked beans, will require more time if grilled in a deep casserole rather than a shallow baking pan.

•Trim excess fat from steaks, chops and roasts, leaving no more than a scant ¼ inch (6.4mm) of fat. Less fat makes cleanup easier, and is a virtual guarantee against unwanted fl are-ups.

•Foods placed on the cooking grate directly above burners may require turning or moving to a less hot area.

•Use tongs rather than a fork for turning and handling meats to avoid losing natural juices. Use two spatulas for handling large whole fi sh.

•If an unwanted fl are-up should occur, turn all burners off and move food to another area of the cooking grate. Any fl ames will quickly subside. After fl ames subside, relight the grill. NEVER USE WATER TO EXTINGUISH FLAMES ON A GAS GRILL.

•Some foods, such as a casserole or thin fi sh fi llets, will require a container for grilling. Disposable foil pans are very convenient, but any metal pan with ovenproof handles can also be used.

•Always be sure the bottom tray and grease catch pan are clean and free from debris.

•Do not line the funnel-shaped bottom tray with foil. This could prevent the grease from fl owing into the grease catch pan.

•Using a timer will help to alert you when “well-done” is about to become “over-done.”

SNAP IGNITION OPERATION

Always open the lid before igniting the burners

Each control knob has its own igniter electrode built in. To create a spark you must push the control knob in (A) and turn to “START/High” (B).

This action will generate gas fl ow and a spark to the burner lighting tube (C). You will hear a “snap” from the igniter. You will also see a 3˝ - 5˝ orange fl ame coming from the burner lighting tube at the left side of the burner (D).

Continue to hold the burner control knob in for two seconds after the “snap”. This will allow gas to fl ow completely down the burner tube (E) and insure ignition.

Check that the burner is lit by looking through the cooking grates. You should see a

flame. If burner does not light on fi rst try, push control knob in and turn to OFF.Repeat lighting procedure a second time.

WARNING: If the burner still does not light, turn the burner control knob to “OFF” and wait 5 minutes to let the gas clear before you try again or try to light with a match.

B

A

E

D

C

WWW.WEBER.COM®