Samsung AR28JQFRAWQ/TV ENGLISH-51, Tightening torque for body cap Refer to the table Spindle

Page 52

Tightening torque for body cap (Refer to the table)

Spindle

Charging core

R-22: Diameter of the screw - 7/16-20UNF

R-410A: Diameter of the screw - 1/2- 20UNF

Tightening torque for charging port cap (Refer to the table)

To check for gas leaks on the outdoor unit,

Check the valve A and B using a leak detector.

To check for gas leaks on the indoor unit,

Check the flare nut C and D using a leak detector.

ffBefore inspecting the leakage, use a torque wrench to close the cap for the service valve. (Comply with a tightening torque for each size of the diameter,and tighten the cap firmly to prevent any leakage.).

ffTo check for any possible leakage, insert inert gas into the pipes connected to indoor/ outdoor units and check the connection part of the indoor/outdoor units with soap lather or liquid for leakage test.

Outer

 

Torque

Diameter

Body cap (N•m)

Charging port

(mm)

cap (N•m)

 

 

ø6.35

20 ~ 25

 

 

ø9.52

20 ~ 25

 

 

ø12.70

25 ~ 30

 

10 ~ 12

ø15.88

30 ~ 35

 

 

ø19.05

35 ~ 40

 

 

(1 N•m = 10 kgf•cm )

05INSTALLATION

Fixing the indoor unit in place

Perform the following work on the area where gas leak test was done priory.

After checking for gas leaks in the system, insulate the pipe, hose and cables.

Then place the indoor unit on the installation plate.

1.To minimise condensation problems, wrap foam insulation (as shown in the figure) on a part without insulation on the end of the pipes.

2.Wind the pipe, assembly cable and drain hose with vinyl tape.

3.Place the bundle (the pipe, assembly cable and drain hose) in the lower part of the indoor unit carefully so it does not project from the rear of the indoor unit.

4.Hook the indoor unit to the installation plate and move the unit to the right and left until it is securely in place.

•Make sure pipe does not move when you install the indoor

CAUTION unit on an installation plate.

5.Wrap the rest of the pipe with vinyl tape.

6.Attach the pipe to the wall using clamps (optional).

Insulation

Pipes

 

Installation

 

plate

Connecting

Vinyl tape

pipes

Connecting wires

 

Drain hose

 

ENGLISH-51

RAC OEM_NOTCODE_IBIM_EN.indd 51

2015-06-12 오후 1:25:15

Page 51 Page 53
Image 52
Page 51 Page 53
Contents RAC OEMNOTCODEIBIMEN.indd 2015 -06 -12 오후 Air Conditioner Thank you for purchasing this Samsung productFeatures of your new air conditioner Cool Summer OfferFast cooling FunctionContents Safety precautions Important safety symbols and precautionsPersonal injury or property damage ENGLISH-4ENGLISH-5 For Power Supply ENGLISH-6For Using ENGLISH-7Do not touch the circuit breaker with wet hands ENGLISH-8Do not operate the appliance with wet hands Do not place objects or devices under the indoor unitENGLISH-9 Do not drink the water from the air conditioner ENGLISH-10Do not clean the inside of the air conditioner by yourself ENGLISH-11Checking before use That may have deposited at low temperaturesENGLISH-12 Display the temperature remote controller setting Checking the name of the partsMain parts DisplayManual operation ENGLISH-14Remote controller buttons Checking the remote controllerENGLISH-15 Remote controller display Low Battery warningStoring the remote controller Inserting the batteriesBasic function ENGLISH-17ENGLISH-18 Press the button to set the desired fan speedInjury when the unit is mishandled Airflow direction ControlVertical air flow Horizontal air flowSetting the On/Off timer Setting the On timer When the air conditioner is offOn timer will ba cancelled ENGLISH-20Setting the Off timer When the air conditioner is on Remote controller displayENGLISH-21 Button withinAir conditioner runs in sleeping mode for 10 hours ModeENGLISH-22 ButtonUsing the Fast function When the air conditioner is operating in Cool/Heat modeCancel ffRepeat the above operation ENGLISH-23Setting the Display option Using the Auto clean functionFunction will be re-activated when the operation stops ENGLISH-24Cleaning the air conditioner Cleaning the indoor unitCleaning the outdoor unit heat exchanger ENGLISH-25Removing the Air filter Cleaning the Air FilterENGLISH-26 If the area of installation is very dusty Maintaining the air conditionerPeriodical checks ENGLISH-27Troubleshooting Timer function ConditionerFan stops and warm air does not come out Length exceeds maximum allowable pipe lengthMaintenance Service callDuring Heat mode in winter RoomGeneral information ENGLISH-31Power supply line, fuse or circuit breaker Installing the unitENGLISH-32 Choosing the installation location Where sulfide gas existsIndoor unit Outdoor UnitENGLISH-34 Air flow directionWhen installing more than 1 outdoor unit ENGLISH-35Accessories Accessories in the indoor unit caseAccessories in the outdoor unit case ENGLISH-36Optional Accessories Tools required for installation General ToolsTools for test operations ENGLISH-37Fixing the installation plate ENGLISH-38If you mount the plate to a concrete wall using plastic Fix the installation plate without inclining to one sideENGLISH-39 Fix the indoor unitConnecting the assembly cable Cable specificationConnecting the cable Electrical work ENGLISH-40Contact during a wiring work ENGLISH-41ENGLISH-42 ENGLISH-43 Cutting or extending the pipe Evacuating the indoor unitENGLISH-44 Put a flare nut slightly into the pipe and modify the flare ENGLISH-459.1 mm 12.8 13.2 mm 16.2 16.6 mm 19.3 19.7 mm Drain hose installation ENGLISH-46Downwards as seen in the picture ENGLISH-47Refer to page 51 for further details ENGLISH-48 Evacuating the connected pipesCycle abnormally high. It may cause explosion and injury Adding Refrigerant Performing the gas leak testsENGLISH-49 Characteristics of the equipment vary ENGLISH-50FfCharge the refrigerant standing the cylinder upright Syphon, upset itCheck the valve a and B using a leak detector Check the flare nut C and D using a leak detectorENGLISH-51 Tightening torque for body cap Refer to the table SpindleENGLISH-52 Final check and trial operationVibration Safe place ENGLISH-53Disconnect the pipes ENGLISH-54 How to connect your extended power cablesTube ENGLISH-55

AR09JQFRAWQ/TV, AR18JQFRAWQ/TV, AR12JQFRAWQ/TV, AR24JQFRAWQ/TV, AR28JQFRAWQ/TV specifications

Samsung has long been a leader in innovative home appliances, and its range of air conditioners, including the AR28JQFRAWQ/TV, AR24JQFRAWQ/TV, AR12JQFRAWQ/TV, AR18JQFRAWQ/TV, and AR09JQFRAWQ/TV models, exemplifies this commitment to quality and technology. These models are designed to ensure optimal comfort with energy efficiency and advanced features tailored to meet the diverse needs of consumers.

One of the standout features of these Samsung air conditioners is the Digital Inverter technology, which significantly enhances energy efficiency. Unlike traditional air conditioners that frequently turn on and off, these models maintain a consistent temperature by adjusting the compressor's speed. This not only helps reduce energy consumption but also prolongs the lifespan of the unit.

Another notable characteristic is the 3-in-1 filter system. This advanced filter setup not only effectively captures dust and allergens but also includes an anti-bacterial layer, ensuring that the air you breathe is clean and safe. This feature is particularly beneficial for families with children or individuals with respiratory conditions.

In terms of cooling performance, the models in this range are equipped with the Fast Cooling function. This feature enables the air conditioners to reach the desired temperature rapidly, providing instant relief during hot weather. Additionally, with its Multi Jet technology, these air conditioners distribute cold air evenly across the room, eliminating hot spots and ensuring a comfortable living environment.

Samsung also emphasizes user convenience with smart control options. Many of these models can be controlled via a smartphone app, allowing users to adjust settings from anywhere. This feature not only enhances usability but also allows for better management of energy consumption, making it easier to keep utility bills in check.

In terms of design, the sleek and modern aesthetic of the AR series blends seamlessly with contemporary home decor. The units are designed to be both functional and visually appealing, making them a great addition to any space.

Overall, Samsung's AR28JQFRAWQ/TV, AR24JQFRAWQ/TV, AR12JQFRAWQ/TV, AR18JQFRAWQ/TV, and AR09JQFRAWQ/TV air conditioners reflect the brand's commitment to innovation, efficiency, and convenience. With features that prioritize user comfort and environmental sustainability, these models are well-suited for modern households seeking reliable and effective climate control solutions. Whether you need a unit for a small room or a larger space, this range offers versatile options tailored to various cooling needs.
Top Page Image Contents