Monessen Hearth CSDV40DLP, CSDV40NDV, CSDV40SNV manual LOG Placement, Place CSDV20 logs in firebox

Page 26

CSDV Series Direct Vent Gas Stove

LOG PLACEMENT

Before you begin — This unit is supplied with ceramic fiber logs. Do not handle these logs with your bare hands. Always wear gloves to prevent skin irritation from ceramic fibers. After handling the logs, wash your hands gently with soap and water to remove any traces of fibers.

WARNING

The positioning of the logs is critical to the safe and clean operation of this heater. Sooting and other problems may result if the logs are not properly and firmly positioned in the appliance. Never add additional logs or embellishments such as pine cones or vermiculite to the heater. Only use the logs supplied with the unit.

Failure to position the parts in accordance with diagrams below or to use only parts specifically approved for this heater may result in property damage or personal injury.

Place CSDV20 logs in firebox

Figure 36

1.Carefully remove logs from wrapping.

2.Open front door of firebox.

3.Place rear log (#1) on rear log pin.

4.Place left base log (#2) on the two pins against left side of firebox.

5.Place right base log (#3) on the two pins against right side of firebox.

Place rock wool (ember material) in firebox

Break up rock wool (ember material) into dime-sized pieces. Fluff up rock wool. Place rock wool evenly across burner surface. Do not block any areas around the perim- eter of the burner, as these are the areas that supply the needed air for secondary combustion. Do not place rock wool under logs. Figure 37

NOTE: Do not exceed one (1) layer of rock wool

Left Base Log #2

Pins

Right Base

Log #3

Rear Log #1

overage. Place a small amount of rock wool on the rear side of the burner only between tabs. The tabs are designed to indicate the area where rock wool location. Do not place rock wool outside the tabs in the back.

REMOTE

CONTROL

 

PILOT

REMOTE

CONTROL

 

PILOT

Figure 36 -

Place CSDV20 Logs on Base

OFF

OFF

Rock Wool

LG813

Figure 37 -

CSDV20 Rock Wool Placement

Pins

LG814

26

58D6056

Page 25 Page 27
Image 26
Page 25 Page 27
Contents Direct Vent Gas Stove ModelsInstallation for Horizontal Termination CongratulationsOwner Important Safety InformationInstaller Important Safety Information Code ApprovalGas Specifications & Orifice Size Product featuresProduct Specifications High ElevationsStove dimensions CSDV20 CSDV30 CSDV40INSTALLATION Information Stove LocationClearances Clearances to combustiblesClearances / Height Requirements Height from Hearth Width Depth ModelLogs Remove Unit from CrateVenting Installation Installation PrecautionsInstalling a Vent System in AN Outside Chase Venting installationInstallation Planning For Horizontal TerminationCanadian Installations1 US Installations2 General Venting Information Termination LocationShaded areas are acceptable Installation for Horizontal TERMI- Nation PurposeVenting installation Horizontal termination configuration examplesHorizontal Venting Horizontal Venting with Two 2 90 ElbowsInstallation for Vertical TERMINA- Tion Horizontal Venting with Three 3 90 ElbowsFlat Ceiling Installation Cathedral Ceiling InstallationVertical Termination CONFIGURA- Tions Venting with Three 3 90 ElbowsNumber Description Simpson Duravent GS 4 X 6B\, Black PipeVenting with Two 2 90 Elbows Check gas type Stove installationInstalling gas piping to fireplace location Natural Gas Electrical Wiring Electrical Installation Remote Wall Mounted SwitchPlace rock wool ember material in firebox LOG PlacementPlace CSDV20 logs in firebox Place CSDV30 Logs in Firebox Place logs and rock wool ember material in fireboxPlace CSDV40 Logs in Firebox Place Rock Wool Ember Material in FireboxOperating Instructions What to do if YOU Smell GASLeak testing Initial lightingPilot position Main burner switchLighting the burner Adjusting the AIR Shutter Firebox Cleaning Cleaning and MaintenanceCleaning Glass Venting SystemGlass Replacement Troubleshooting Observed Problem Possible Cause RemedyReplacement Parts Replacement Parts Description QtyCSDV30 Replacement Parts Replacement Parts CSDV30NV CSDV30PVCSDV40 Replacement Parts CSDV40NV CSDV40PV Carbon Monoxide Detector Requirements If Warranty Service is Needed Mhsc

CSDV20SLP, CSDV40SLP, CSDV40NDV, CSDV20DLP, CSDV20DNV specifications

Monessen Hearth has established itself as a trusted name in the fireplace and heating industry, providing innovative and stylish solutions for residential warming needs. Among its esteemed lineup, the Monessen CSDV series offers a range of direct vent gas stoves that combine functionality with aesthetic appeal. The five notable models in this series are the CSDV40NDV, CSDV40DLP, CSDV20SNV, CSDV20DLP, and CSDV20SLP, each designed to cater to different preferences and needs while delivering exceptional performance.

The CSDV40NDV and CSDV40DLP are both 40-inch models that stand out for their impressive heating capacity and larger burn area. The CSDV40NDV features a stunning, traditional style including arched glass doors that enhance its elegance. The deep ceramic glass provides an expansive view of the flickering flames, while the optional blower increases efficiency by distributing heat throughout the room. The CSDV40DLP, on the other hand, offers a more contemporary design, integrating clean lines and modern aesthetics but still providing the same impressive heating capabilities.

Shifting focus to the CSDV20 models, the CSDV20SNV and CSDV20DLP are both 20-inch units, perfect for smaller spaces or for creating a cozy ambiance without overwhelming a room. The CSDV20SNV features a stylish traditional design with a sleek black finish and decorative detailing, while the CSDV20DLP offers a more modern take, showcasing clean lines and simplicity. Both models benefit from advanced technology that allows them to maintain consistent temperatures while efficiently utilizing fuel.

All models in the CSDV series feature Monessen's patented burner technology, which produces realistic flames and ensures efficient operation. With direct vent capabilities, these stoves safely vent combustion gases outside, making them a clean and safe option for homeowners. Additionally, they boast easy-to-use thermostatic controls that empower users to maintain their desired temperature effortlessly.

Energy efficiency is another hallmark of the CSDV range, with many units qualifying for efficiency rebates depending on local utilities. Overall, the Monessen Hearth CSDV series offers a compelling combination of style, efficiency, and advanced technology, making it an excellent choice for anyone looking to enhance their indoor space with a dependable heating solution.
Top Page Image Contents