User’s Information Guide
High Efficiency Oil Furnaces
Highboy Vertical, Lowboy Front or Rear Flue, Downflow / Horizontal
GENERAL INFORMATION
Understand the signal words WARNING, AND CAUTION. These words are safety alert words. WARNING indicates hazards which could result in personal injury or death.
CAUTION is used to indicate unsafe practices which could result in minor injury or property damage.
▲! WARNING
DO NOT use this furnace if any component was underwater. Immediately call a qualified heating contractor to inspect the furnace and replace any part of the furnace control system that was underwater. This furnace does not have a pilot light. It is equipped with an electronic ignition system that automatically lights the burner.
IMPORTANT FACTS
The flow of combustion and ventilating air must not be obstructed from reaching the furnace. Air openings provided in the casing of the furnace must be kept free of obstructions which would restrict airflow, thereby affecting efficiency and safe operation of your furnace.
Also, air openings provided to the area in which the furnace is installed and the space around the furnace shall not be blocked or obstructed. Keep this in mind should you choose to remodel the area which contains your furnace.
The furnace and venting system require a generous amount of clean air to operate safely. Lack of adequate combustion and ventilation air can result in erratic operation of the burner, noisy and poor combustion, sooting of the combustion chamber, and fuel odors in the air. Never block off or restrict the supply of air to the furnace.
The combustion air for your furnace must be fresh unconta- minated air. Paints, varnishes, laundry bleaches, detergents, many household cleaners, water softening salts, adhesives, and all such products release fumes containing compounds which could lead to early heat exchanger and vent system deteriora- tion. Do not store these types of products near your furnace.
Never store gasoline, combustible materials, or other flammable liquids or vapors near your furnace.
▲! WARNING
TO PREVENT AN EXPLOSION OR POSSIBLE INJURY, DEATH AND EQUIPMENT DAMAGE, DO NOT STORE COMBUSTIBLE MATERIALS, GASOLINE OR OTHER FLAMMABLE VAPORS OR LIQUIDS NEAR THE UNIT.
Carbon monoxide, fire or smoke can cause serious bodily injury, death, and/or property damage.
A variety of potential sources of carbon monoxide can be found in a building or dwelling such as
Contents
Dangers, Warnings & Cautions | 1 |
|
|
General Information | 1 |
To Start the Furnace |
|
2 | |
Proper Maintenance |
|
3 | |
|
|
The Problem Solver | 4 |
Regular Dealer Maintenance |
|
5 | |
Warranties |
|
|
|
|
|
The U.S. Consumer Product Safety Commission recommends that users of
NOTE:
The manufacturer of your furnace does not test any detec- tors and makes no representations regarding any brand or type of detector.
Installing and servicing heating equipment can be hazardous due to fuel oil and electrical components. Only trained and qualified personnel should install, repair or service heating equipment.
Untrained personnel can perform basic maintenance functions such as cleaning and replacing air filters. All other operations must be performed by trained service personnel.
Parts and controls of this furnace are unique. Should service or modification be required, be sure your servicer uses only factory authorized parts, kits, or accessories for this furnace.
If you experience a problem with the operation of your furnace, check the “Problem Solver” section of this manual before you call for a possibly unneeded service call.