Heat & Glo LifeStyle ST-CFL-24LP, CFL-30LP-B, CFL-24LP-B, CFL-18LP-B manual Introduction, Assembly

Page 15

1.0 INTRODUCTION

The information in this manual pertains to Models CFL- 18 NG/LP-B, CFL-24 NG/LP-B, CFL-30 NG/LP-B and ST-CFL-24NG/LP.

Gas Log Sets are Decorative Gas Appliances for Instal- lation in a Solid-fuel Burning Fireplace. Minimum fire- place sizes for these models are shown in Figures 1, 2, 3 and 4.

WARNING: This log set must NOT be installed in an unvented appliance.

This log set is to be installed only in a solid-fuel burn- ing fireplace with a working flue and one constructed of noncombustible material. The minimum permanent vent opening provided by the fireplace chimney damper to vent the flue products must not be less than 51 square inches (328cm2). The chimney damper MUST be fixed in a manner to maintain the minimum perma- nent vent opening. This may be accomplished by fas- tening the damper stop clamp provided to the edge of the damper to prevent its closing.

WARNING: OPEN THE CHIMNEY DAMPER TO ITS FULLY OPEN POSITION WHEN BURNING THIS GAS LOG SET.

WARNING: LOGS MUST NEVER BE BURNED WITHOUT THE FLUE DAMPER IN THE FULL OPEN POSITION. FAILURE TO DO SO IS DANGEROUS TO YOUR HEALTH AND VOIDS ALL WARRANTIES.

WARNING: ALL GAS APPLIANCES PRODUCE SOME CARBON MONOXIDE WHEN OPERATED. CARBON MONOXIDE IS A COLORLESS, ODOR- LESS, POISONOUS GAS. ADEQUATE PROVISIONS MUST BE MADE TO PROVIDE COMBUSTION AIR FOR THIS GAS LOG SET. IF OUTSIDE AIR IS NOT INCLUDED IN THE FIREPLACE, IT MAY BE NEC- ESSARY THAT AN ADDITIONAL COMBUSTION AIR SOURCE BE PROVIDED.

CAUTION: CHECK THE CONSTRUCTION OF THE FIREPLACE BEFORE INSTALLING THE GAS LOG SET. THE AREA OF THE FLUE SHOULD NOT BE LESS THAN 1/11 THE AREA OF THE FIREPLACE OPENING NON-AIRTIGHT GLASS DOORS SHOULD BE INSTALLED ON THE FIREPLACE IF THE AREA OF THE FLUE IS LESS THAN 1/11 THE AREA OF THE FIREPLACE OPENING.

CAUTION: To minimize the possibility of spillage and to maximize proper draft, position the log set as close to the back of the fireplace as possible. The ST- CFL-24 log set should be positioned in the center of the unit.

The installation, including provisions for combustion and ventilation air, must conform with the National Fuel Gas Code ANSI Z223.1 (in the United States), the CAN/ CGA B-149 Installation Code (in Canada) and appli- cable local building codes.

These models can be installed in a bedroom (in the United States) which has a total volume of unconfined space appropriate to the particular installation. Refer to the National Fuel Gas Code ANSI Z223.1/NFPA 54- (current edition). The Uniform Mechanical Code (cur- rent edition), and Local Building Officials for the options allowed in obtaining an effective bedroom volume of un- confined space.

Always keep the appliance area clear and free from combustible materials, gasoline, and other flammable vapors and liquids.

Do not use this appliance if any part has been under water. Immediately call a qualified service technician to inspect the unit and to replace any part of the control system and any gas control which has been under water.

WARNING: THIS UNIT IS NOT FOR USE WITH SOLID FUEL. SOLID FUELS SHALL NOT BE BURNED IN A FIREPLACE WHERE A DECORATIVE APPLIANCE IS INSTALLED.

2.0 ASSEMBLY

CAUTION: WHEN INSTALLING THIS LOG SET IN A FACTORY BUILT FIREPLACE, BE CERTAIN TO CONSULT THE FIREPLACE INSTALLATION MANUAL. ALL KNOCKOUTS IN THE FIREPLACE THROUGH WHICH THE GAS SUPPLY LINE IS RUN MUST BE RESEALED WITH INSULATION AFTER THE GAS LINE IS IN PLACE.

These models contain complete gas-burner, grate(s), and log components needed. Use caution when han- dling logs to avoid damage. Position the gas-burner

assembly to the rear of the fireplace. The ST-CFL-24 log set should be positioned in the center of the unit. Once fully assembled, the front log will extend forward of the burner assembly.

A.Run proper size gas line into fireplace. A 1/2 inch (13mm) gas line, with a 3/8 inch (10mm) reduction for hook-up, is usually sufficient for the Gas Log set; how- ever, if the run is unusually long, a larger line may be required. Contact your local gas company or Depart- ment of Building and Safety if there are any questions.

Heat & Glo • CFL-18/24/30-B, ST-CFL-24 • 526-900 Rev. F • 7/05

15

Page 14 Page 16
Image 15
Page 14 Page 16
Contents Installationand Operation Instructions Table of Contents CFL-18-B Service Parts List / Liste des pièces de rechange CFL-18-B CFL-24-B Service Parts List / Liste des pièces de rechange CFL-24-B CFL-30-B Service Parts List / Liste des pièces de rechange CFL-30-B ST-CFL-24 ST-CFL-24 Service Parts List / Liste des pièces de rechangeModel CFL-18-B Model CFL-24-B Model CFL-30-B Model ST-CFL-24 Introduction AssemblyHeat & Glo CFL-18/24/30-B, ST-CFL-24 526-900 Rev. F 7/05 LPG Propane Information Operating Guidelines and Maintenance InstructionsFor Your Safety Read Before Lighting Safety InformationTo Turn OFF GAS Appliance Lighting InstructionsHigh Elevation Installation Limited Lifetime Warranty Heat & GLO GAS Appliance Products

CFL-24LP-B, CFL-30LP-B, CFL-18LP-B, ST-CFL-24LP specifications

Heat & Glo has established itself as a leader in the fireplace and heating solutions industry, and its LifeStyle series further solidifies this reputation. Within this innovative range, models such as the ST-CFL-24LP, CFL-18LP-B, CFL-24LP-B, and CFL-30LP-B stand out for their aesthetic appeal, efficient heating capabilities, and advanced technology.

One of the main features of these models is their contemporary design. Each unit is crafted with a sleek finish, making them an ideal addition to modern living spaces. The large fire viewing area provides an enhanced visual experience, allowing users to enjoy the mesmerizing flames from multiple angles. The clean, linear lines and minimalist framing options enable these fireplaces to seamlessly integrate into various interior designs.

Efficiency and performance are at the forefront of the LifeStyle series. Each model is equipped with a powerful heating system that employs innovative technology to provide maximum heat output while optimizing energy use. This ensures that not only will the space be heated effectively, but it will also remain cost-efficient, making it a great choice for environmentally conscious consumers.

The LifeStyle ST-CFL-24LP and its counterparts feature advanced electronic ignition systems, enhancing reliability while simplifying operation. With the easy-to-use remote control, users can adjust the flame height, heat settings, and even set timers, providing convenience and customized comfort at the touch of a button.

Moreover, these models incorporate ventless technology that allows for versatile installation options. This feature means there is no need for extensive venting, making it easier for homeowners to find the perfect spot for their fireplace without the constraints of traditional models. Whether placed in a living room, bedroom, or even outdoors, the LifeStyle series offers flexibility while ensuring safe operation.

Safety is also a critical consideration with the LifeStyle fireplaces. Each unit comes with built-in safety features, including automatic shut-off systems and flame sensors, ensuring peace of mind while the fireplace is in use.

In summary, the Heat & Glo LifeStyle ST-CFL-24LP, CFL-18LP-B, CFL-24LP-B, and CFL-30LP-B models are designed for those seeking a combination of aesthetics, efficiency, and advanced technology. With their contemporary styling, efficient heating capabilities, and user-friendly features, these models stand out as premium choices for any modern home setting.
Top Page Image Contents